John Deere JDLink 2G 3G MTG Technical Manual TM114519 05DEC19 PDF

Table of contents
FOREWORD
ZXLINK™
Section 210 – GENERAL INFORMATION
Group 05A – Safety
Recognize Safety Information
Understand Signal Words
Follow Safety Instructions
Practice Safe Maintenance
Use Steps and Handholds Correctly
Handle Electronic Components and Brackets Safely
Avoid Exposure to High Radio Frequency Fields
Group 05B – General References
Information Available in Sections, Groups and Subgroups
Glossary of Terms
3 Levels of Service for JDLink (Connect, Select, and Ultimate)
Group 05C – References for Technical Information
Required Components
Optional Components
Customer Owned SIM Replacement Procedures
Group 20 – Theory of Operation
JDLink™ Theory of Operation
Group 100A – Factory Support Information
Documentation for a Well Prepared DTAC Case
Section 211 – DIAGNOSTIC TROUBLE CODES
Group JDL – JDLink / ZXLink Diagnostic Trouble Codes (JDL)
JDL – 000237.11 – JDL Not Registered
JDL – 000639.09 – JDL Not Detecting CAN Bus Messages
JDL – 000841.05 – GPS Antenna Error – Open Circuit
JDL – 000841.06 – GPS Antenna Error – Grounded/Short Circuit
JDL – 000964.13 – Real Time Clock Failure
JDL – 002850.02 – Cellular Antenna Error – Abnormal Signal
JDL – 002850.05 – Cellular Antenna Error – Open Circuit
JDL – 002850.06 – Cellular Antenna Error – Grounded/Short Circuit
JDL – 002852.11 – Unable to Detect SIM Card
JDL – 516672.14 – Network Authorization Failed
JDL – 522976.11 – Unable to Load Custom Alerts
JDL – 522976.13 – Unable to Load Configuration
JDL – 523310.00 – Low Disk Space
JDL – 600006.31 – Vehicle Controls Not Operating Correctly
Group JL2 – JDLink 2 Diagnostic Trouble Codes (JL2)
JL2 – 000237.11 – JL2 Not Registered
JL2 – 000639.09 – JL2 Not Detecting CAN Bus Messages
JL2 – 000841.05 – GPS Antenna Error – Open Circuit
JL2 – 000841.06 – GPS Antenna Error – Grounded/Short Circuit
JL2 – 000964.12 – Real Time Clock Failure
JL2 – 000964.13 – Real Time Clock Failure
JL2 – 002850.02 – Cellular Antenna Error – Abnormal Signal
JL2 – 002850.05 – Cellular Antenna Error – Open Circuit
JL2 – 002850.06 – Cellular Antenna Error – Grounded/Short Circuit
JL2 – 002852.11 – Unable to Detect SIM Card
JL2 – 522976.11 – Unable to Load Custom Alerts
JL2 – 522976.13 – Unable to Load Configuration
JL2 – 523310.00 – Low Disk Space
Section 212 – OBSERVABLE SYMPTOM AND SYSTEM DIAGNOSTICS
Group 45 – Electronic Control Units
Terminal is not listed or unable to see terminal in JDLink
Machine cannot call into JDLink or Machine shows Pending Registration in JDLink
Machine not paired with terminal in JDLink or Machine shows Unregistered in JDLink
Terminal shows Uninstalled in JDLink
No Ultimate data or missing Ultimate data in JDLink
Engine Hours Incorrect or do not Update
Current Machine Location is not showing in JDLink
JDL (or JL2) does not appear on machine or JDL (or JL2) Controller ‘Selected Device is not responding” message appearing
Network Diagnostics Page does not populate MTG information
Remote Display Access unable to connect or establish call
Outside USA – Network Diagnostics unable to connect or establish call
Wireless Data Transfer unable to send/receive file – stuck processing
Satellite Module: Satellite not activated or registered in JDLink
MTG is not receiving automatic updates and requires new firmware
Satellite Modem Coverage
Customer SIM – Registration status Uninstalled or Pending Registration
Customer SIM – Machine stopped communicating
Customer SIM – Cannot communicate with machine via Call Now Feature
Section 245 – ELECTRONIC CONTROL UNITS
Group 05 – General Information
Servicing Electronic Control Units
Welding Near Electronic Control Units
Keep Electronic Control Unit Connectors Clean
Accessing Diagnostic Trouble Codes and Diagnostic Addresses
Activate JDLink™
JDLink™ Web Registration
Service ADVISOR™ Registration
Transfer Terminal
JDLink / ZXLink Setup
MTG Voltages
Group 10A – Operational and Preliminary Checks
JDLink / ZXLink Problem
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Group 10B – Interactive Tests and Calibrations
General Information Test
Group 30 – Schematic
Ag Satellite Harness Schematic
Ag Universal Harness Schematic
Construction and Forestry Harness Schematic
Dual MTG (JDL and JL2) Controllers on Machine
Group 50 – Diagnostic Tests and Adjustments
JDLink / ZXLink Problem
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Service ADVISOR Remote Problem
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Procedure
Group JDL – JDLink Controller Software Addresses (JDL)
JDLink / ZXLink Diagnostic Addresses
Group JL2 – Modular Telematics Gateway Software Addresses (JL2)
JL2 Diagnostic Addresses
Section 249 – ELECTRICAL COMPONENT INFORMATION
Group 05 – General Information
How to navigate Section 249
Connector Information
Antenna Connections
Group 40F – Fuses
F6000 – Battery Positive Fuse
F6001 – Battery Negative Fuse
F6002 – Ignition Fuse
Group 40G – Charging
G6000 – Battery Negative Terminal
X6012 – Battery Positive Terminal
Group 40W – Wiring Harnesses
Harness Information
Machine Specific JDLink Harnesses
Ethernet Cable
W6001 – Machine Specific Harness
W6002 – MTG Adapter Harness
W6003 – Ag Satellite Harness
Group 40X – Interconnects and Ground Points
X6000 – MTG Control Unit Connector
X6001 – GPS Connection Connector
X6002 – Cellular Connection Connector
X6003 – Cab Harness Connector
X6004 – Satellite Module Connector
X6005 – Satellite Antenna Connector
X6006 – EDL/Service ADVISOR Connector
X6014 – MTG (JDL) Control Unit Connector
X6015 – Satellite Module Connector
X6016A – Satellite Adapter Harness Connector
X6016B – Satellite Adapter Harness Connector
X6019 – EDL/Service ADVISOR Harness Connector
X6020 – MTG Control Unit Connector
X6021 – GreenStar RS232 Connector
X6022 – Analog Input Connector
X6023 – Cab Harness Connector
X6024 – M2M Module Connector
X6025 – Satellite Module Connector
X6026 – MTG (JL2) Control Unit Connector
X6027 – GPS Connection Connector
X6028 – Cellular Connection Connector
Group 40Z – Connector Repair Procedures
CINCH CINCH is a trademark of Cinch Inc. Flexbox Connectors
Repair DEUTSCH DEUTSCH is a trademark of Deutsch Company Connectors
Repair Molex Connector
Repair Weather Pack Weather Pack is a trademark of Packard Electric Connector