John Deere PowerTech 6135 Level 32 ECU Diesel Engine Component Technical Manual CTM119919 PDF

Table of contents
FOREWORD
RECORD OF CHANGES
IDENTIFICATION VIEWS
RELATED MANUALS
TRAINING INFORMATION
DEFINITION OF TERMS
TRADEMARKS
Section 01 – GENERAL INFORMATION
Group 000 – Safety
Understand Signal Words
Recognize Safety Information
Replace Safety Signs
Follow Safety Instructions
California Proposition 65 Warning
Exhaust Filter Cleaning
Avoid Hot Exhaust
Work In Ventilated Area
Decommissioning: Proper Recycling and Disposal of Fluids and Components
Prevent Machine Runaway
Practice Safe Maintenance
Work in Clean Area
Wear Protective Clothing
Service Machines Safely
Use Proper Tools
Construct Dealer-Made Tools Safely
Support Machine Properly
Use Proper Lifting Equipment
Protect Against Noise
Illuminate Work Area Safely
Install All Guards
Stay Clear of Rotating Drivelines
Protect Against High Pressure Spray
Service Cooling System Safely
Remove Paint Before Welding or Heating
Precautions for Welding
Wait Before Opening High-Pressure Fuel System
Avoid High-Pressure Fluids
Avoid Heating Near Pressurized Fluid Lines
Avoid Static Electricity Risk When Refueling
Handle Fluids Safely—Avoid Fires
Prepare for Emergencies
Handling Batteries Safely
Prevent Acid Burns
Prevent Battery Explosions
Live With Safety
Group 001 – Engine Identification
Engine Serial Number Plate Information
OEM Engine Option Code Label
Information Relative to Emissions Regulations
Emissions Control System Certification Label
Group 002 – Fuels, Lubricants, and Coolant
Diesel Exhaust Fluid (DEF) — Use in Selective Catalytic Reduction (SCR) Equipped Engines
Storing Diesel Exhaust Fluid (DEF)
Refilling Diesel Exhaust Fluid (DEF) Tank
Testing Diesel Exhaust Fluid (DEF)
Disposal of Diesel Exhaust Fluid (DEF)
Diesel Fuel
Supplemental Diesel Fuel Additives
Lubricity of Diesel Fuel
Handling and Storing Diesel Fuel
BioDiesel Fuel
Testing Diesel Fuel
Fuel Filters
Minimizing the Effect of Cold Weather on Diesel Engines
John Deere Break-In Plus™ Engine Oil — Interim Tier 4, Final Tier 4, Stage IIIB, and Stage IV
Diesel Engine Oil — Interim Tier 4, Final Tier 4, Stage IIIB, and Stage IV
Engine Oil and Filter Service Intervals — Interim Tier 4, Final Tier 4, Stage IIIB, and Stage IV — OEM Applications
Diesel Engine Oil and Filter Service Intervals
Mixing of Lubricants
Alternative and Synthetic Lubricants
Lubricant Storage
Oil Filters
Diesel Engine Coolant (engine with wet sleeve cylinder liners)
Water Quality for Mixing with Coolant Concentrate
Operating in Warm Temperature Climates
Testing Coolant Freeze Point
Disposing of Coolant
Section 02 – REPAIR AND ADJUSTMENTS
Group 010 – Engine Rebuild
Overhaul Guidelines
Check Air Intake System
Check and Service Cooling System
Check Crankcase Ventilation System
Check Electrical System
Check Exhaust System
Clean Engine
Disconnect Turbocharger Oil Supply Lines
Engine Assembly Sequence
Engine Break-In Guidelines
Engine Disassembly Sequence
General Tune-Up Recommendations
Install Adapters on Repair Stand
Lift Strap — Installation
Lift Strap — Removal
Lifting Procedure
Engine Repair Stand Adapter — Installation
Engine Break-In
Engine Repair Stand – Adapter Safety Precautions
Sealant Application Guidelines
Group 020 – Cylinder Head and Valve Repair and Adjustment
Cylinder Head — Cleaning and Inspection
Cylinder Head — Flatness Check
Cylinder Head — Installation
Cylinder Head — Removal
Cylinder Head Gasket — Inspection
Cylinder Head Injector Bore — Cleaning and Inspection
Fuel Injector Sleeves — Installation
Fuel Injector Sleeve — Removal
Rocker Arm Access Panel — Installation
Rocker Arm Access Panel — Removal
Rocker Arm Cover — Installation
Rocker Arm Cover — Removal
Rocker Arm Cover Heat Shield — Installation
Rocker Arm Cover Heat Shield — Removal
Rocker Arm Injector — Inspection
Rocker Arm Intake and Exhaust — Inspection
Rocker Arm Shaft — Inspection
Rocker Arm Shaft Assembly— Assemble
Rocker Arm Shaft Assembly — Installation
Rocker Arm Shaft Assembly — Removal
Rocker Arm Shaft Assembly — Tear Down
Valve — Cleaning and Inspection
Valve — Clearance Adjustment and Injector Preload
Valve — Grinding
Valve — Measurement
Valve — Recess Measurement
Valve Assembly — Installation
Valve Assembly — Removal
Valve Bridge, Valve Rotator, and Valve Retainer — Inspection
Valve Guide — Cleaning and Measurement
Valve Guide — Installation
Valve Guide — Measurement
Valve Guide — Removal
Valve Seat — Cleaning and Inspection
Valve Seat — Grinding
Valve Seat Insert — Installation
Valve Seat Insert — Removal
Valve Spring — Inspection and Measurement
Group 030 – Cylinder Block, Liners, Pistons, and Rods Repair and Adjustment
Connecting Rod and Cap — Inspection
Connecting Rod Bearing — Inspection and Measurement
Connecting Rod Bushing — Inspection
Cylinder Block — Cleaning and Inspection
Cylinder Block Oil and Coolant Plug — Installation
Cylinder Liner — Cleaning
Cylinder Liner — Inspection
Cylinder Liner — Installation and Height Measurement
Cylinder Liner — Measure Liner Flange Thickness
Cylinder Liner — Removal
Cylinder Liner Shim — Installation
Oil Dipstick Tube Assembly — Inspection
Oil Dipstick Tube Assembly — Installation
Oil Dipstick Tube Assembly — Removal
Oil Filler and Dipstick Assembly — Installation
Oil Filler and Dipstick Assembly — Removal
Piston — Cleaning
Piston — Inspection
Piston and Connecting Rod Assembly — Installation
Piston and Connecting Rod Assembly — Removal
Piston and Connecting Rod Assembly — Tear Down
Piston Cooling Orifice — Installation
Piston Cooling Orifice — Removal and Inspection
Piston Pin and Bore — Inspection
Piston Pin Bushing — Inspection
Piston to Liner — Clearance Check
Group 040 – Crankshaft, Main Bearings, Flywheel Repair, and Adjustment
Crankshaft — End Play Check
Crankshaft — Inspection
Crankshaft — Installation
Crankshaft — Removal
Crankshaft Front Oil Seal Hub — Installation
Crankshaft Front Oil Seal Hub — Removal
Crankshaft Gear — Replacement
Crankshaft Grinding — Guidelines
Crankshaft Main Bearing — Oil Clearance Check
Crankshaft Journals — Assembled Measurements
Crankshaft Pulley — Installation
Crankshaft Pulley — Removal
Crankshaft Unitized Front Oil Seal — Installation
Crankshaft Unitized Front Oil Seal — Removal
Crankshaft Unitized Rear Oil Seal — Installation
Crankshaft Unitized Rear Oil Seal — Removal
Crankshaft Unitized Rear Oil Seal Housing — Installation
Crankshaft Unitized Rear Oil Seal Housing — Removal
Crankshaft Vibration Damper — Inspection
Crankshaft Vibration Damper and Hub — Installation
Crankshaft Vibration Damper and Hub — Removal
Flywheel — Inspection
Flywheel — Installation
Flywheel — Removal
Flywheel Face — Runout Check
Flywheel Housing — Installation
Flywheel Housing — Removal
Flywheel Pilot Bearing Bore — Concentricity Runout Check
Flywheel Ring Gear — Installation
Flywheel Ring Gear — Removal
Main Bearing Cap — Installation
Main Bearing Cap — Line Bore Specifications
Main Bearing Cap — Removal
Thrust Bearing — Inspection
Thrust Bearing and Main Bearing Cap — New Part Specification
Group 050 – Camshaft and Timing Gear Train Repair and Adjustment
Air Compressor Assembly — Installation
Air Compressor Assembly — Removal
Auxiliary Gear Drive Front Cover — Installation
Auxiliary Gear Drive Front Cover — Removal
Auxiliary Gear Drive Rear Cover — Installation
Auxiliary Gear Drive Rear Cover — Removal
Auxiliary Drive Crankshaft Driven Front Mounted SAE A — Installation
Auxiliary Drive Crankshaft Driven Front Mounted SAE A — Removal
Auxiliary Drive Crankshaft Driven Front Mounted SAE B — Installation
Auxiliary Drive Crankshaft Driven Front Mounted SAE B — Removal
Auxiliary Drive Crankshaft Driven Rear Mounted SAE B — Installation
Auxiliary Drive Crankshaft Driven Rear Mounted SAE B — Removal
Auxiliary Drive Crankshaft Driven Idler Gear — Installation
Auxiliary Drive Crankshaft Driven Idler Gear — Removal
Camshaft — Check End Play
Camshaft — Inspection
Camshaft — Removal
Camshaft and Gear — Installation
Camshaft Bushing — Measurement
Camshaft Bushing — Replacement
Camshaft Gear — Inspection
Camshaft Gear — Removal
Camshaft Gear Access Cover — Installation
Camshaft Gear Access Cover — Removal
Camshaft Follower — Inspection
Camshaft Journal — Measurement
Camshaft Lobe — Lift Measurement
Camshaft Position Sensor Lobe — Inspection
Camshaft Retaining Ring — Installation
Camshaft Retaining Ring — Removal
Camshaft Retaining Ring — Thickness Measurement
Camshaft Timing Pin
Camshaft to Crankshaft Timing — Check and Adjustment
Coolant Pump Idler Gear — Installation
Coolant Pump Idler Gear — Removal
Front Seal Housing — Installation
Front Seal Housing — Removal
High-Pressure Fuel Pump Drive Pin — Replacement
Timing Gear Cover — Installation
Timing Gear Cover — Removal
Timing Gears — Check Backlash
Upper Idler Gear — Installation
Upper Idler Gear — Removal
Group 060 – Lubrication System Repair and Adjustment
Dipstick Assembly — Installation
Dipstick Assembly — Removal
Oil Cooler— Inspection
Oil Cooler— Installation
Oil Cooler— Removal
Oil Cooler Bypass Valve — Installation
Oil Cooler Bypass Valve — Removal
Oil Filler— Installation
Oil Filler — Removal
Oil Filter — Installation
Oil Filter — Removal
Oil Filter and Oil Cooler Housing Assembly — Installation
Oil Filter and Oil Cooler Housing Assembly — Removal
Oil Filter Bypass Valve — Installation
Oil Filter Bypass Valve — Removal
Oil Pan — Installation
Oil Pan — Removal
Oil Pan Drain Valve — Installation
Oil Pan Drain Valve — Removal
Oil Pickup Tube — Installation
Oil Pickup Tube — Removal and Inspection
Oil Pressure Regulating Valve — Installation
Oil Pressure Regulating Valve — Removal
Oil Pump — Assemble
Oil Pump — Installation
Oil Pump — Removal
Oil Pump — Tear Down and Inspect
Open Crankcase Ventilation System — Inspection
Open Crankcase Ventilation System — Installation
Open Crankcase Ventilation System — Removal
Group 070 – Cooling System Repair and Adjustment
Accessory Belt — Installation
Accessory Belt — Removal
Accessory Mounting Bracket — Installation
Accessory Mounting Bracket — Removal
Accessory Belt Tensioner — Installation
Accessory Belt Tensioner — Removal
Belt Tensioner — Spring Tension and Belt Wear Check
Coolant Bypass Tube — Installation
Coolant Bypass Tube — Removal
Coolant Heater — Servicing
Coolant Pump — Visual Inspection
Coolant Pump Assembly — Installation
Coolant Pump Assembly — Removal
Coolant System — Air Bleeding
Fan Drive Assembly — Installation
Fan Drive Assembly — Removal
Fan Drive Belt — Installation
Fan Drive Belt — Removal
Fan Drive Belt Tensioner — Installation
Fan Drive Belt Tensioner — Removal
Fan Drive Belt Tensioner Bracket — Installation
Fan Drive Belt Tensioner Bracket — Removal
Idler Pulley Assembly — Installation
Idler Pulley Assembly — Removal
Idler Pulley Mounting Bracket — Installation
Idler Pulley Mounting Bracket — Removal
Rear Top Liner Coolant Return Line — Installation
Rear Top Liner Coolant Return Line — Removal
Thermostat — Installation
Thermostat — Removal
Thermostat Cover — Installation
Thermostat Cover — Removal
Thermostat Housing — Installation
Thermostat Housing — Removal
Group 080 – Air Intake and Exhaust System Repair and Adjustment – PowerTech PSS
Air Intake Tube and Adapter — Installation
Air Intake Tube and Adapter — Removal
Air System ? Component View
Air Throttle Actuator Bracket — Installation
Air Throttle Actuator Bracket — Removal
EGR Cooler — Installation
EGR Cooler — Removal
EGR Cooler Bracket — Installation
EGR Cooler Bracket — Removal
EGR Cooler Coolant Return Line — Installation
EGR Cooler Coolant Return Line — Removal
EGR Cooler Coolant Supply Line — Installation
EGR Cooler Coolant Supply Line — Removal
EGR Cooler Gas Inlet Pipe — Installation
EGR Cooler Gas Inlet Pipe — Removal
EGR Cooler Gas Outlet Pipe — Installation
EGR Cooler Gas Outlet Pipe — Removal
EGR Flow Venturi — Installation
EGR Flow Venturi — Removal
EGR Flow Venturi Bracket — Installation
EGR Flow Venturi Bracket — Removal
EGR Flow Venturi Coolant Return Line — Installation
EGR Flow Venturi Coolant Return Line — Removal
EGR Flow Venturi Coolant Supply Line — Installation
EGR Flow Venturi Coolant Supply Line — Removal
EGR Flow Venturi Inlet Pipe — Installation
EGR Flow Venturi Inlet Pipe — Removal
EGR Mixer Assembly — Installation
EGR Mixer Assembly — Removal
EGR System — Component View
EGR Valve Actuator Bracket — Installation
EGR Valve Actuator Bracket — Removal
Exhaust Manifold — Installation
Exhaust Manifold — Removal and Inspection
Extending Turbocharger Life
Intake Manifold — Installation
Intake Manifold — Removal and Inspection
Turbocharger — Break-In
Turbocharger — Failure Analysis
Turbocharger — Inspection
Turbocharger Compressor Interstage — Installation
Turbocharger Compressor Interstage — Removal
Turbocharger, Fixed — Installation
Turbocharger, Fixed — Removal
Turbocharger, Fixed Oil Drain Line — Installation
Turbocharger, Fixed Oil Drain Line — Removal
Turbocharger, Fixed Oil Supply Line — Installation
Turbocharger, Fixed Oil Supply Line — Removal
Turbocharger Turbine Interstage — Installation
Turbocharger Turbine Interstage — Removal
Turbocharger, VGT — Installation
Turbocharger, VGT — Removal
Turbocharger, VGT Actuator Coolant Return Line — Installation
Turbocharger, VGT Actuator Coolant Return Line — Removal
Turbocharger, VGT Actuator Coolant Supply Line — Installation
Turbocharger, VGT Actuator Coolant Supply Line — Removal
Turbocharger, VGT Actuator Linkage — Installation
Turbocharger, VGT Actuator Linkage — Removal
Turbocharger, VGT Oil Drain Line — Installation
Turbocharger, VGT Oil Drain Line — Removal
Turbocharger, VGT Oil Supply Line — Installation
Turbocharger, VGT Oil Supply Line — Removal
Group 090 – Electronic Fuel System Repair and Adjustment
Electronic Injectors — Cleaning (In Engine)
Electronic Unit Injector — Installation
Electronic Unit Injector — Removal
Electronic Unit Injector Body — Cleaning
Electronic Unit Injector Body — Inspection
Electronic Unit Injector Bore — Cleaning
Electronic Unit Injector Orifice — Cleaning
Fuel Filter — Installation
Fuel Filter — Removal
Fuel Filter Header — Component Assembly
Fuel Filter Header Assembly— Installation
Fuel Filter Header Assembly — Removal
Fuel Filter Header Fitting — Replacement
Fuel Filter Header Sensor Manifold — Installation
Fuel Filter Header Sensor Manifold — Removal
Fuel Supply and Leak-off Lines — Installation
Fuel Supply and Leak-off Lines — Removal
ECU Fuel Inlet Line — Installation
ECU Fuel Inlet Lines — Removal
Fuel System Air— Bleeding
High-Pressure Fuel Pump — Installation
High-Pressure Fuel Pump — Removal
Injector Wiring Harness — Installation
Injector Wiring Harness — Removal
Low-Pressure Fuel Pump — Installation
Low-Pressure Fuel Pump — Removal
Group 100 – OEM Starting and Charging Systems Repair and Adjustment
Alternator — Installation
Alternator — Removal
Starter Motor — Installation
Starter Motor — Removal
Group 110 – Electrical Engine Control Repair and Adjustment
Electrical Engine Control Component Location Diagram 1
Electrical Engine Control Component Location Diagram 2
Electrical Engine Control Component Location Diagram 3
Electrical Engine Control Component Location Diagram 4
Electrical Engine Control Component Location Diagram 5
Electrical Engine Control Component Location Diagram 6
Aftertreatment Inlet NOx Sensor — Installation
Aftertreatment Inlet NOx Sensor — Removal
Aftertreatment Outlet NOx Sensor — Installation
Aftertreatment Outlet NOx Sensor — Removal
Air Throttle Actuator — Installation
Air Throttle Actuator — Removal
Camshaft Position Sensor — Installation
Camshaft Position Sensor — Removal
Charge Air Cooler Outlet Air Temperature Sensor — Installation
Charge Air Cooler Outlet Air Temperature Sensor — Removal
Crankshaft Position Sensor — Installation
Crankshaft Position Sensor — Removal
DPF Differential Pressure Sensor — Installation
DPF Differential Pressure Sensor — Removal
EGR Flow Sensor and Heat Shield — Installation
EGR Flow Sensor and Heat Shield — Removal
EGR Temperature Sensor — Installation
EGR Temperature Sensor — Removal
EGR Valve — Installation
EGR Valve — Removal
Engine Control Unit (ECU) — Maintenance
Engine Control Unit (ECU) and Mounting Bracket — Installation
Engine Control Unit (ECU) and Mounting Bracket — Removal
Engine Coolant Pressure Sensor — Installation
Engine Coolant Pressure Sensor — Removal
Engine Coolant Temperature Sensor — Installation
Engine Coolant Temperature Sensor — Removal
Engine Oil Pressure Sensor — Installation
Engine Oil Pressure Sensor — Removal
Aftertreatment Temperature Module — Installation
Aftertreatment Temperature Module — Removal
Exhaust Manifold Pressure Sensor — Installation
Exhaust Manifold Pressure Sensor — Removal
Fuel Dosing Inlet Sensor — Installation
Fuel Dosing Inlet Sensor — Removal
Fuel Dosing Outlet Pressure Sensor — Installation
Fuel Dosing Outlet Pressure Sensor — Removal
Fuel Temperature Sensor — Installation
Fuel Temperature Sensor — Removal
Intake Air Sensor — Installation
Intake Air Sensor — Removal
Intake Manifold Air Pressure (MAP) Sensor — Installation
Intake Manifold Air Pressure (MAP) Sensor — Removal
Intake Manifold Air Temperature (MAT) Sensor — Installation
Intake Manifold Air Temperature (MAT) Sensor — Removal
Low-Pressure Fuel Pressure Sensor — Installation
Low-Pressure Fuel Pressure Sensor — Removal
High-Pressure Fuel Pressure Sensor — Installation
High-Pressure Fuel Pressure Sensor — Removal
Low-Pressure Fuel System Jumper Harness — Installation
Low-Pressure Fuel System Jumper Harness — Removal
SCR Temperature Module — Installation
SCR Temperature Module — Removal
Turbocharger, Fixed, Compressor Outlet Temperature Sensor — Installation
Turbocharger, Fixed, Compressor Outlet Temperature Sensor — Removal
VGT Actuator — Installation
VGT Actuator — Removal
VGT Speed Sensor — Installation
VGT Speed Sensor — Removal
Water-In-Fuel (WIF) Sensor — Installation
Water-In-Fuel (WIF) Sensor — Removal
Wiring Harness — Installation
Wiring Harness — Removal
Wiring Harness — Routing
Group 112 – Connector Repair and Adjustment
Connectors
Installation of Repair Wire Assembly (RWA)
Repair AMP® Seal 16 – Type ‘A” Connectors
Repair AMP® Seal 16 – Type ‘B” Connectors
Repair AMP® Seal 16 – Type ‘C” Connectors
Repair Bosch Connectors
Repair DEUTSCH Connectors
Repair Metri-Pack™ Connectors
Repair Tyco HDSCS Connectors
Repair WEATHER PACK® Connectors
Using High-Pressure Washing
Group 115 – Fuel Dosing Aftertreatment Devices Repair and Adjustment
Diesel Oxidation Catalyst (DOC) — Cleaning
Diesel Particulate Filter Maintenance and Service
DPF Differential Pressure Sensor Manifold Fittings — Installation
DPF Differential Pressure Sensor Manifold Fittings — Removal
Exhaust Filter — Assemble
Exhaust Filter — Cleaning
Exhaust Filter — Diesel Particulate Filter Ash Handling and Disposal
Exhaust Filter — Disposal
Exhaust Filter — Handling
Exhaust Filter — Tear Down and Inspection
Exhaust Filter, Brackets, and Piping — Installation
Exhaust Filter, Brackets, and Piping — Removal
Exhaust Filter Inlet Piping — Installation
Exhaust Filter Inlet Piping — Removal
Fuel Dosing Injector — Installation
Fuel Dosing Injector — Removal
Fuel Dosing Pump — Installation
Fuel Dosing Pump — Removal
Fuel Dosing Pump Assembly — Assemble
Fuel Dosing Pump Assembly — Installation
Fuel Dosing Pump Assembly — Removal
Fuel Dosing Pump Assembly — Tear Down
Fuel Dosing System Fuel Lines — Installation
Fuel Dosing System Fuel Lines — Removal
Fuel Dosing Unit — Installation
Fuel Dosing Unit — Removal
Fuel Dosing Injector Coolant Line Fittings — Installation
Fuel Dosing Injector Coolant Line Fitting — Removal
Group 116 – DEF Dosing Aftertreatment Devices Repair and Adjustment
DEF Decomposition Tube — Cleaning
DEF Decomposition Tube — Installation
DEF Decomposition Tube — Removal
DEF Dosing Injector — Cleaning
DEF Dosing Injector — Installation
DEF Dosing Injector — Removal
DEF Dosing System Lines — Installation
DEF Dosing System Lines — Removal
DEF Dosing Unit — Installation
DEF Dosing Unit — Removal
DEF Dosing Unit Filter — Installation
DEF Dosing Unit Filter — Removal
DEF Dosing Unit Fittings — Installation
DEF Dosing Unit Fittings — Removal
DEF Dosing System Coolant Filter— Installation
DEF Dosing System Coolant Filter — Removal
DEF Dosing System Coolant Lines — Installation
DEF Dosing System Coolant Lines — Removal
DEF Tank Header Assembly — Installation
DEF Tank Header Assembly — Removal
DEF Tank Header Suction Screen — Installation
DEF Tank Header Suction Screen — Removal
DEF Tank Header — Breather and Fittings Assembly
DEF Tank Heater Coolant Control Valve Solenoid — Installation
DEF Tank Heater Coolant Control Valve Solenoid — Removal
Selective Catalyst Reduction (SCR) — Cleaning
Selective Catalyst Reduction (SCR) — Cleaning and Inspection
Selective Catalyst Reduction (SCR) — Disposal
Selective Catalyst Reduction (SCR) — Handling
Selective Catalyst Reduction (SCR), Brackets, and Piping — Installation
Selective Catalyst Reduction (SCR), Brackets, and Piping — Removal
Section 03 – THEORY OF OPERATION
Group 120 – Base Engine
Engine Sectional View Component Location Diagrams
General Engine Operation
Head Gasket Joint Construction and Operation
Group 123 – Cooling System
Component Location Diagrams
Cooling System Operation
Group 126 – Lubrication System
Component Location Diagrams
Lubrication System Operation
Group 130 – Electronic Fuel System
Electronic Fuel System Component Location Diagram 1
Electronic Unit Injector (EUI) Operation
Fuel System Operation
High-Pressure Fuel Pump Operation
High-Pressure Fuel System Operation
Low-Pressure Fuel Pump Operation
Low-Pressure Fuel System Operation
Primary and Secondary Fuel Filter Operation
Group 135 – Air Intake and Exhaust System
Air Intake and Exhaust System Component Location Diagram 1
Air Intake and Exhaust System Component Location Diagram 2
Air Intake and Exhaust System Component Location Diagram 3
Air Intake and Exhaust System Component Location Diagram 4
Air Intake and Exhaust System Operation
Air Throttle Actuator Operation
Ether Start Aid Operation
EGR Cooler Operation
EGR Valve Operation
Fixed Turbocharger Operation
VGT Operation
Group 137 – Aftertreatment System
Aftertreatment Component Location Diagram 1
Aftertreatment Component Location Diagram 2
Aftertreatment Component Location Diagram 3
Aftertreatment System Operation
DEF Dosing Injector Operation
DEF Dosing Unit Operation
DEF Tank Header Operation
Exhaust Filter Operation
Fuel Dosing Injector Operation
Fuel Dosing Pump Operation
Fuel Dosing Unit Operation
SCR Operation
SCR System Derates
Group 140 – Electrical Control System
Analog Throttle
A5507 — DEF Tank Header Assembly Connector
B5000 — Fuel Dosing Inlet Sensor
B5009 — Engine Coolant Level Alarm Switch
B5010 — Engine Coolant Level Information Switch
B5101 — Engine Oil Pressure Sensor
B5102 — Exhaust Manifold Pressure Sensor
B5103 — EGR Flow Sensor
B5104 — Manifold Air Pressure (MAP) Sensor
B5106 — Fuel Dosing Outlet Pressure Sensor
B5107 — High-Pressure Fuel Pressure Sensor
B5108 — Engine Coolant Pressure Sensor
B5109 — DPF Differential Pressure Sensor
B5110 — Low-Pressure Fuel Pressure Sensor
B5200 — Fixed Turbocharger Compressor Outlet Temperature Sensor
B5204 — Aftertreatment Temperature Module
B5205 — Charge Air Cooler Outlet Temperature Sensor
B5206 — Manifold Air Temperature (MAT) Sensor
B5207 — EGR Temperature Sensor
B5208 — Engine Coolant Temperature Sensor
B5209 — Fuel Temperature Sensor
B5212 — SCR Temperature Module
B5300 — VGT Speed Sensor
B5301 — Crankshaft Position Sensor
B5302 — Camshaft Position Sensor
B5500 — Intake Air Sensor
B5501 — DEF Dosing Unit
B5502 — Aftertreatment Inlet NOx Sensor
B5503 — Aftertreatment Outlet NOx Sensor
B5600 — Water-In-Fuel Sensor
Barometric Air Pressure Sensor
Combination Throttle
Controller Area Network (CAN)
Controller Area Network (CAN) Throttle
Cruise Control Operation
Determining Engine Speed and Piston Position
Digital Throttle
E5601 — DEF Dosing Unit Pressure Line Heater
E5602 — DEF Dosing Unit Supply Line Heater
E5603 — DEF Dosing Unit Return Line Heater
Engine Control Unit (ECU) System Operation
Engine Control Unit (ECU) Temperature Sensor
Engine Derate and Shutdown Protection
Governor Droop Mode Selection
Measuring Pressure
Measuring Speed
Measuring Temperature
Pilot Injection Operation
Pulse-Width-Modulated (PWM) Throttle
Sensor Supply #1
Sensor Supply #2
Sensor Supply #3
Sensor Supply #4
Sensor Supply #5
Sensor Supply #6
Sensor Supply #7
Sensor Supply #8
Sensor Supply #9
Sensor Supply #10
Throttle Adjustments
Throttle Offset
Throttle Self-Calibration
Torque Speed Control (TSC)
X5023 — Fuel Injector Harness (6-Pin)
X5024 — Fuel Injector Harness (8-Pin)
Y5000 — Fuel Dosing Shutoff Valve
Y5001 — Fuel Dosing Control Valve
Y5005 — Variable Speed Fan
Y5020 — DEF Dosing Injector
Y5400 — EGR Valve
Y5401 — Air Throttle Actuator
Y5500 — VGT Actuator
Y5501 — Low-Pressure Fuel Pump
Y5502 — Fuel Dosing Pump
Section 04 – DIAGNOSTICS
Group 150 – Observable Diagnostics
Abnormal Engine Noise
Coolant in Oil or Oil in Coolant
Diagnostic Procedure
Blank Diagnostic Gauge Check
Terminal Check
Supply Voltage Check
Ground Wire Check
Service ADVISOR Communication Check
Terminal Check
Continuity Check
Blank Diagnostic Gauge Check
Terminal Check
Supply Voltage Check
Ground Wire Check
Service ADVISOR Communication Check
Terminal Check
Continuity Check
Diagnostic Procedure
Preliminary Checks
Bluetooth Check
USB Check
Reboot Computer
EDL Check
EDL Cable Check
Supply Circuit Check
Open Circuit Check
High Resistance Check
High Resistance Check
Operator Interface Check
Connect To Other Application
Equipment Check
Preliminary Checks
Bluetooth Check
USB Check
Reboot Computer
EDL Check
EDL Cable Check
Supply Circuit Check
Open Circuit Check
High Resistance Check
High Resistance Check
Operator Interface Check
Connect To Other Application
Equipment Check
Diagnostic Procedure
Preliminary Checks
ECU Check
Original ECU Communication Check
Preliminary Checks
ECU Check
Original ECU Communication Check
Diagnostic Procedure
Sensor Check
Thermostat Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Return Circuit Check
Replace Sensor
Sensor Check
Thermostat Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Return Circuit Check
Replace Sensor
Diagnostic Procedure
Preliminary Checks
Attempt to connect with Service ADVISOR
Perform Harness Diagnostic Mode Test
Terminal Check
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Cranking Speed Check
Abnormal Engine Noise Check
Cold Weather Check
Low-Pressure Fuel System Test
Check Fuel Quality
High-Pressure Fuel System Test
Compression Check
Perform Camshaft to Crankshaft Timing Check
Air Throttle Actuator Check
Valve Clearance Check
Preliminary Checks
Attempt to connect with Service ADVISOR
Perform Harness Diagnostic Mode Test
Terminal Check
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Cranking Speed Check
Abnormal Engine Noise Check
Cold Weather Check
Low-Pressure Fuel System Test
Check Fuel Quality
High-Pressure Fuel System Test
Compression Check
Perform Camshaft to Crankshaft Timing Check
Air Throttle Actuator Check
Valve Clearance Check
Diagnostic Procedure
Check for Active DTCs
Perform Harness Diagnostic Mode Test
Preliminary Checks
Monitor Sensors
Throttle Test
Governor Selection Check
Check Engine Load
Reprogram ECU
Intake and Exhaust Restriction and Air Leak Test
Exhaust Check
Check for Misfire
Charge Air System Analysis
Low-Pressure Fuel Supply System Test
Check Fuel Quality
High-Pressure Fuel Supply System Test
Air Throttle Actuator Check
Check EGR Valve and EGR Cooler
Valve Clearance Check
Clean Injectors
Check on Dynamometer
Replace Injectors
Check for Active DTCs
Perform Harness Diagnostic Mode Test
Preliminary Checks
Monitor Sensors
Throttle Test
Governor Selection Check
Check Engine Load
Reprogram ECU
Intake and Exhaust Restriction and Air Leak Test
Exhaust Check
Check for Misfire
Charge Air System Analysis
Low-Pressure Fuel Supply System Test
Check Fuel Quality
High-Pressure Fuel Supply System Test
Air Throttle Actuator Check
Check EGR Valve and EGR Cooler
Valve Clearance Check
Clean Injectors
Check on Dynamometer
Replace Injectors
Diagnostic Procedure
Check for Black Smoke
Check for Black Smoke
Diagnostic Procedure
Smoke Check
Smoke Check
Diagnostic Procedure
Smoke Check
Smoke Check
Diagnostic Procedure
Check for Active DTCs
Items Possibly Mistaken As Misfire or Irregular Running Engine
Camshaft Position and Crank Position Signal Test
Check for Crank Sensor Pattern Problem
Check for Camshaft Position Pattern Problem
Check Throttle
Misfire and Cut-Out Test
Check Compression
Check Valve Adjustment and Injector Preload
Clean Injectors
Reprogram ECU
Verification
Check for Air in Fuel
Fuel Quality
Low-Pressure Fuel Supply System Test
High-Pressure Fuel Supply System Test
Clean Injectors
Check for Active DTCs
Items Possibly Mistaken As Misfire or Irregular Running Engine
Camshaft Position and Crank Position Signal Test
Check for Crank Sensor Pattern Problem
Check for Camshaft Position Pattern Problem
Check Throttle
Misfire and Cut-Out Test
Check Compression
Check Valve Adjustment and Injector Preload
Clean Injectors
Reprogram ECU
Verification
Check for Air in Fuel
Fuel Quality
Low-Pressure Fuel Supply System Test
High-Pressure Fuel Supply System Test
Clean Injectors
Diagnostic Procedure
Preliminary Checks
Check Battery State of Charge
Check Battery Voltage While Attempting Crank
Load Test Batteries
Check Starter Relay Battery Supply Voltage
Check Voltage at Starter Relay Coil
Check Starter Relay Coil Ground
Check Starter Relay Output Voltage
Check Starter Solenoid Control Circuit
Check Starter Cables
Check Key Switch Voltage Supply
Check Key Switch
Verification
Preliminary Checks
Check Battery State of Charge
Check Battery Voltage While Attempting Crank
Load Test Batteries
Check Starter Relay Battery Supply Voltage
Check Voltage at Starter Relay Coil
Check Starter Relay Coil Ground
Check Starter Relay Output Voltage
Check Starter Solenoid Control Circuit
Check Starter Cables
Check Key Switch Voltage Supply
Check Key Switch
Verification
Diagnostic Procedure
Preliminary checks
Warm Engine Oil Level Check
Oil Pressure Check
OCV Speed Check
Sludge Check
Check Breather Baffle
Check Breather Baffle
OCV Cleaning
OCV Speed Check Inlet Disconnected
OCV Cleaning
OCV Speed Check
Oil Accumulation Check
Preliminary checks
Warm Engine Oil Level Check
Oil Pressure Check
OCV Speed Check
Sludge Check
Check Breather Baffle
Check Breather Baffle
OCV Cleaning
OCV Speed Check Inlet Disconnected
OCV Cleaning
OCV Speed Check
Oil Accumulation Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Frequent Regeneration Check
DEF System Leaks
DEF Tank Level Visual Inspection
NOx Sensor Check
ECU Reprogram
Read DTCs and Store Snapshot Information
Frequent Regeneration Check
DEF System Leaks
DEF Tank Level Visual Inspection
NOx Sensor Check
ECU Reprogram
Excessive Fuel Consumption
Diagnostic Procedure
Oil In Coolant Check
Excessive Crankcase Pressure Check
Pistons, Rings, Cylinder Liners Check
Oil In Coolant Check
Excessive Crankcase Pressure Check
Pistons, Rings, Cylinder Liners Check
Frequent Regenerations
Diagnostic Procedure
Inspect Fuel Cooler (If equipped)
Compression Check
Inspect Fuel Cooler (If equipped)
Compression Check
Diagnostic Procedure
Oil Contamination Test
Check for Restricted Fuel Return Lines
Check for Black Smoke
Check Engine Performance
Check for Loose Injector Clamp
Check Injectors
Deteriorated in cross hole drill of head
Check Cylinder Head for Cracks
Oil Contamination Test
Check for Restricted Fuel Return Lines
Check for Black Smoke
Check Engine Performance
Check for Loose Injector Clamp
Check Injectors
Deteriorated in cross hole drill of head
Check Cylinder Head for Cracks
JDLink Does Not Communicate with ECU
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Low-Pressure Fuel Test
High-Pressure Fuel Test
Throttle Response Test
Reprogram ECU
Throttle Response Test
Read DTCs and Store Snapshot Information
Low-Pressure Fuel Test
High-Pressure Fuel Test
Throttle Response Test
Reprogram ECU
Throttle Response Test
Group 155 – Checks, Tests, and Procedures
Aftertreatment Verification Procedure
Air in Fuel Check
CAN Message Not Received
CAN Message Received Error
CAN Message Received Is Incorrect
Carbon Removal Procedure
Charge Air Cooler Test
Cooling System Test
Diagnostic Procedure
Maximum Crankcase Pressure Test
VGT Test
Fixed Geometry Turbocharger Test
Determining Blow-by Contribution of Turbos
Determining if VGT is the Problem
Determining if Fixed Geometry Turbocharger is the Problem
Electronic Compression Test
Cylinder Cutout Test
Cylinder Leak Down Test
Maximum Crankcase Pressure Test
VGT Test
Fixed Geometry Turbocharger Test
Determining Blow-by Contribution of Turbos
Determining if VGT is the Problem
Determining if Fixed Geometry Turbocharger is the Problem
Electronic Compression Test
Cylinder Cutout Test
Cylinder Leak Down Test
DEF Dosing System — Cleaning
DEF Quality Check
DEF Quantity Test
EGR Cooler Test
Diagnostic Procedure
Verify Problem
Terminal Check
Communication Status Check
Terminal Check
Communication Status Check
Terminal Check
Communication Status Check
Terminal Check
Communication Status Check
CAN Low Voltage Check
Terminal Check
Continuity Check
Short to Ground Check
CAN Shorted Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Verify Problem
Terminal Check
Communication Status Check
Terminal Check
Communication Status Check
Terminal Check
Communication Status Check
Terminal Check
Communication Status Check
CAN Low Voltage Check
Terminal Check
Continuity Check
Short to Ground Check
CAN Shorted Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Engine Cranking Speed Check
Engine Oil Pressure Check
Diagnostic Procedure
Exhaust Check
Exhaust Filter Inspection
Investigate Potential Air System Problems
Low-Pressure Fuel Supply System Test
High-Pressure Fuel Supply System Test
ECU Reprogram
Valve Check
Check for Type of White Smoke
Engine Temperature Verification
Cutout Test
Compression Check
Check Fuel Quality
Reprogram ECU
White Smoke Check
Cooling System Check
EGR Cooler Check
Compression Check
Cylinder Head Check
Compression Check
Turbocharger Oil Seal Check
Crankcase Pressure Check
Smoke Verification
Fuel Quality
Exhaust Check
Exhaust Filter Inspection
Investigate Potential Air System Problems
Low-Pressure Fuel Supply System Test
High-Pressure Fuel Supply System Test
ECU Reprogram
Valve Check
Check for Type of White Smoke
Engine Temperature Verification
Cutout Test
Compression Check
Check Fuel Quality
Reprogram ECU
White Smoke Check
Cooling System Check
EGR Cooler Check
Compression Check
Cylinder Head Check
Compression Check
Turbocharger Oil Seal Check
Crankcase Pressure Check
Smoke Verification
Fuel Quality
Diagnostic Procedure
Fuel Dosing System Air Purge procedure
Verify DOC Temperatures
ETM Issue Check
Service Regeneration
Fuel Dosing System Air Purge procedure
Verify DOC Temperatures
ETM Issue Check
Service Regeneration
Fuel Return Line Restriction Check
Check Fuel Supply Quality Diagnostic Procedure
Low-Pressure Fuel System Test
Replace Fuel Filters
Temporary Known Good Fuel Supply Installation
Low-Pressure Fuel System Test
Replace Fuel Filters
Temporary Known Good Fuel Supply Installation
Diagnostic Procedure
Purge Air
Purge Air Again
Enable Low-Pressure Fuel Pump
Other checks
Fuel Filter Header Check
Purge Air
Purge Air Again
Enable Low-Pressure Fuel Pump
Other checks
Fuel Filter Header Check
Diagnostic Procedure
Check for leaks on full fuel system
Check for Air Leaking into Crankcase
Check Fuel Filter Assembly for Leakage
Check for Air Leaking in the Cylinder head
Check for leaks on full fuel system
Check for Air Leaking into Crankcase
Check Fuel Filter Assembly for Leakage
Check for Air Leaking in the Cylinder head
Diagnostic Procedure
Check for Active DTCs
Low-Pressure Fuel System Test
Check Gauge Pressure
Compare High-Pressure Fuel – Actual Pressure to Gauge Pressure
Compare High-Pressure Fuel Pressure Gauges
Terminal Check
Sensor Supply Circuit Check
Sensor Ground Circuit Check
Sensor Signal Circuit Check
Software Check
Terminal Check
Continuity Check
Reprogram ECU
Other Possible Causes
DTC Check
Check for Active DTCs
Low-Pressure Fuel System Test
Check Gauge Pressure
Compare High-Pressure Fuel – Actual Pressure to Gauge Pressure
Compare High-Pressure Fuel Pressure Gauges
Terminal Check
Sensor Supply Circuit Check
Sensor Ground Circuit Check
Sensor Signal Circuit Check
Software Check
Terminal Check
Continuity Check
Reprogram ECU
Other Possible Causes
DTC Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Replace Fuel Filters
Mechanical Pressure Check
Check Fuel Pressure
Visual Leak check
Check for Air in Fuel
O-ring Check
Replace Fuel Filter Head
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Terminal Check
Signal Circuit Check
Check Low-Pressure Fuel Pump Flow
Read DTCs and Store Snapshot Information
Replace Fuel Filters
Mechanical Pressure Check
Check Fuel Pressure
Visual Leak check
Check for Air in Fuel
O-ring Check
Replace Fuel Filter Head
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Terminal Check
Signal Circuit Check
Check Low-Pressure Fuel Pump Flow
Mechanical Compression Check
NOx Conversion Efficiency Validation Test Diagnostic Procedure
Preliminary Check
SCR Performance Check
Code Check
Preliminary Check
SCR Performance Check
Code Check
Diagnostic Procedure
Terminator Check
Terminal Check
Voltage Check
Short Ground Check
Terminal Check
Continuity Check
Continuity Check
Terminal Check
Continuity Check
Continuity Check
Additional Checks
Terminal Check
Continuity Check
Verification
Terminator Check
Terminal Check
Voltage Check
Short Ground Check
Terminal Check
Continuity Check
Continuity Check
Terminal Check
Continuity Check
Continuity Check
Additional Checks
Terminal Check
Continuity Check
Verification
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Obtain More Information
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
Obtain More Information
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Unswitched Voltage Check
Signal Circuit Continuity Check
Wire to Wire Short Check
Wire to Wire Short Check
Unswitched Voltage Check
Signal Circuit Continuity Check
Wire to Wire Short Check
Wire to Wire Short Check
Terminal Test
Thermostat — Testing
Turbocharger Oil Seal Leak Check
Venturi — Cleaning
Diagnostic Procedure
DTC Check
Perform Harness Diagnostic Mode Test
Operating Conditions
Operating Conditions
DTC Check
Perform Harness Diagnostic Mode Test
Operating Conditions
Operating Conditions
Wiggle Test
Group 160 – Diagnostic Instructions and Information
Air Throttle Actuator Learn Value Reset Test Instructions
Clear Aftertreatment Latched DTC — Test Instructions
Communication Error Test Instructions
Connecting to Service ADVISOR
Control Unit Information and Overview Test
Cylinder Cutout Test Instructions
Cylinder Electronic Compression Test Instructions
Cylinder Misfire Test Instructions
Data Points Used in Service ADVISOR
DEF Dosing System High Flow Rate Test
DEF Dosing System Test
DEF Header Coolant Purge Test
DEF Pump Diagnostic Test
Diagnostic Gauge — Main Menu
Diagnostic Gauge — Using
Diagnostic Test Box — Using
Diagnostic Trouble Code Designations
Digital Multimeter — Using
DOC Calibration — Instructions
DPF Calibration — Instructions
EGR Valve — Clean Test Instructions
EGR Valve — Learn Value Reset Instructions
Electrical Circuit Concepts
Electrical Noise — Possible Causes
Electronic Injector — Calibration Information
Emission Control System Derate Temporary Override
Enable Low-Pressure Fuel Pump
Engine Control Unit (ECU) — Donating this Engines’ ECU to be Used Elsewhere
Engine Control Unit (ECU) — Replacing Current ECU with Another ECU
Engine Control Unit (ECU) — Replacing Current ECU with Another ECU — Cannot Communicate with Current ECU
Engine Control Unit (ECU) — Reprogramming Current ECU
Engine Control Unit (ECU) — Reprogramming Instructions
Engine Hours — Updating Instructions
Engine Overspeed Verification Test
ESM Operator Action Information Decoder — Instructions
Exhaust Temperature Management Test Instructions
Frequent Regeneration Test — Instructions
Fuel Dosing Pump Diagnostic Test
Fuel Dosing System Air Purge Instructions
Harness Diagnostic Mode Test
Interactive Tests and Calibration Results — Printing, Exporting, or Saving Instructions
Internal Data Monitor — Instructions
Keep Electronic Control Unit Connectors Clean
Load Profile Information Test — Instructions
Lost ECU Data Reset Test
Payload File — Downloading Instructions
Payload File — Replacement Engine ECU Payload Downloading Instructions
Regeneration Abort Source Identification Test — Instructions
Regeneration Failure — Possible Causes
SCR Calibration — Instructions
SCR System Performance Verification Test
Service Regeneration Instructions
Servicing Electronic Control Units
Snapshot Instructions
Trim Options Information
VGT — Learn Value Reset Instructions
View Non-Clearable DTCs — Test Instructions
Welding Near Electronic Control Units
Group 161 – DTC SPN – 000001—000199
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Supply Circuit Check
Circuit Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Check Codes
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Supply Circuit Check
Circuit Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Check Codes
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Check Codes
000027.07 – EGR Valve Desired and Actual Position Mismatch
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
000028.14 – Digital Throttle Inhibited
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
000029.14 – Secondary Analog Throttle Inhibited
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Check Codes
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Check Codes
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Check Codes
000051.07 – Air Throttle Actuator Desired and Actual Position Mismatch
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Continuity Check
Check Codes
Read DTCs and Store Snapshot Information
Continuity Check
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
000091.09 – Primary Analog Throttle Signal Erratic
000091.14 – Primary Analog Throttle Inhibited
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Return System Check
Terminal Check
Signal Circuit Check
Signal Circuit Check
Check Codes
Read DTCs and Store Snapshot Information
Code Check
Return System Check
Terminal Check
Signal Circuit Check
Signal Circuit Check
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Check Codes
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Check Codes
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Check Codes
000094.17 – Low-Pressure Fuel Signal Slightly Low
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Check Codes
Check Codes
Read DTCs and Store Snapshot Information
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Check Codes
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Water in Fuel Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
ECU Check
Prime Fuel System
Engine Running DTC Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Water in Fuel Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
ECU Check
Prime Fuel System
Engine Running DTC Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
000097.16 – Water-In-Fuel Level Moderately High
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Verify Sensor Operation
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Read DTCs and Store Snapshot Information
Verify Sensor Operation
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Ground Circuit Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Ground Circuit Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
000100.18 – Engine Oil Pressure Signal Moderately Low
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Code Check
Code Check
Boost Leak Check
Terminal Check
Supply Circuit Check
Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Read DTCs and Store Snapshot Information
Code Check
Code Check
Code Check
Code Check
Boost Leak Check
Terminal Check
Supply Circuit Check
Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Boost Leak Check
Wiring Check
Injector Wiring Check
VGT Check
Reprogram ECU
Read DTCs and Store Snapshot Information
Boost Leak Check
Wiring Check
Injector Wiring Check
VGT Check
Reprogram ECU
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Noise Check
Terminal Check
VGT Speed Sensor Circuit Check
Terminal Check
Continuity Check
Wire to Wire Check
Electrical Noise Check
VGT Speed Sensor Check
VGT Shaft Check
Read DTCs and Store Snapshot Information
Noise Check
Terminal Check
VGT Speed Sensor Circuit Check
Terminal Check
Continuity Check
Wire to Wire Check
Electrical Noise Check
VGT Speed Sensor Check
VGT Shaft Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
High Resistance Check
Terminal Check
Short to Ground Check
Wire to Wire Check
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
High Resistance Check
Terminal Check
Short to Ground Check
Wire to Wire Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Replace Sensor
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Replace Sensor
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
000105.15 – Manifold Air Temperature Signal Slightly High
000105.16 – Manifold Air Temperature Signal Moderately High
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Check Codes
ECU Reprogram
Read DTCs and Store Snapshot Information
Check Codes
ECU Reprogram
000107.15 – Air Filter Pressure Differential Slightly High
000107.16 – Air Filter Pressure Differential Moderately High
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Preliminary Check
Reprogram ECU
Review Snapshot Information
Read DTCs and Store Snapshot Information
Preliminary Check
Reprogram ECU
Review Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Preliminary Check
Check Codes
Reprogram ECU
Air Vent Check
Read DTCs and Store Snapshot Information
Preliminary Check
Check Codes
Reprogram ECU
Air Vent Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Verification
Read DTCs and Store Snapshot Information
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Verification
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
000109.17 – Engine Coolant Pressure Signal Slightly Low
000109.18 – Engine Coolant Pressure Signal Moderately Low
000109.31 – Engine Coolant Pressure Signal Fault
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Verify Sensor Operation
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Replace Sensor
Cooling System Check
Thermostat Test
Check Coolant Pump
Check for Plugged Radiator
Check Fan
Check Fan Speed
Check Fan Speed
Read DTCs and Store Snapshot Information
Verify Sensor Operation
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Replace Sensor
Cooling System Check
Thermostat Test
Check Coolant Pump
Check for Plugged Radiator
Check Fan
Check Fan Speed
Check Fan Speed
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
000110.15 – Engine Coolant Temperature Signal Slightly High
000110.16 – Engine Coolant Temperature Signal Moderately High
000110.17 – Engine Coolant Temperature Signal Slightly Low
Diagnostic Procedure
Verify Problem
Switch Status Check
Verify Trim Settings
Terminal Check
Switch Check
Return Circuit Check
Intermittent Short to Voltage Check
Verify Problem
Switch Status Check
Verify Trim Settings
Terminal Check
Switch Check
Return Circuit Check
Intermittent Short to Voltage Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Level Switch Voltage Check
Level Switch Status Check
Level Switch Status Check
Alarm Switch Status Check
Terminal Check
Alarm Switch Status Check
Switch Check
Terminal Check
Continuity Check
ECU Reprogram
Terminal Check
Alarm Switch Status Check
Swap Connector Check
Terminal Check
Level Switch Status Check
Read DTCs and Store Snapshot Information
Level Switch Voltage Check
Level Switch Status Check
Level Switch Status Check
Alarm Switch Status Check
Terminal Check
Alarm Switch Status Check
Switch Check
Terminal Check
Continuity Check
ECU Reprogram
Terminal Check
Alarm Switch Status Check
Swap Connector Check
Terminal Check
Level Switch Status Check
Diagnostic Procedure
Verify Problem
Coolant Level Check
Verify OEM Parts
Level Switch Voltage Check
Level Switch Status Check
Level Switch Status Check
Terminal Check
Switch Check
Return Circuit Check
Switch Check
Intermittent Open Circuit Check
Terminal Check
Terminal Check
Verify Problem
Coolant Level Check
Verify OEM Parts
Level Switch Voltage Check
Level Switch Status Check
Level Switch Status Check
Terminal Check
Switch Check
Return Circuit Check
Switch Check
Intermittent Open Circuit Check
Terminal Check
Terminal Check
000111.18 – Engine Coolant Level Alarm Switch Activated at Moderate Coolant Temperature
000137.00 – Auxiliary Gauge Pressure Reading Extremely High
000137.01 – Auxiliary Gauge Pressure Reading Extremely Low
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Ground Circuit Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Continuity Check
Check Codes
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Ground Circuit Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Continuity Check
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Supply Circuit Check
Ground Circuit Check
Signal Circuit Check
Software Check
Terminal Check
Continuity Check
Reprogram ECU
Terminal Check
Short to Signal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Check Codes
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Supply Circuit Check
Ground Circuit Check
Signal Circuit Check
Software Check
Terminal Check
Continuity Check
Reprogram ECU
Terminal Check
Short to Signal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Check Codes
000157.18 – High-Pressure Fuel Signal Moderately Low
000158.01 – Battery Voltage Extremely Low
Diagnostic Procedure
Reprogram ECU and Store Snapshot Information
Replace ECU
Reprogram ECU and Store Snapshot Information
Replace ECU
000158.31 – Keyswitch Battery Potential Error
000160.02 – Primary Shaft Speed Invalid
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Voltage Check
Terminal Check
Power Circuit Check
Open or High Resistance Circuit Check
Power Circuit Check
Open or High Resistance Circuit Check
Power Circuit Check
Open or High Resistance Circuit Check
Power Circuit Check
Open or High Resistance Circuit Check
Power Circuit Check
Open or High Resistance Circuit Check
Power Circuit Check
Open or High Resistance Circuit Check
Reprogram ECU
Read DTCs and Store Snapshot Information
Voltage Check
Terminal Check
Power Circuit Check
Open or High Resistance Circuit Check
Power Circuit Check
Open or High Resistance Circuit Check
Power Circuit Check
Open or High Resistance Circuit Check
Power Circuit Check
Open or High Resistance Circuit Check
Power Circuit Check
Open or High Resistance Circuit Check
Power Circuit Check
Open or High Resistance Circuit Check
Reprogram ECU
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Voltage Check
Reprogram ECU
Read DTCs and Store Snapshot Information
Voltage Check
Reprogram ECU
000168.18 – Unswitched Battery Voltage Moderately Low
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Fuel Heater Check
Fuel Heater Disconnected Check
Fuel Heater Connected Check
Sensor Check
Terminal Check
Circuit Check
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
ECU Check
Read DTCs and Store Snapshot Information
Fuel Heater Check
Fuel Heater Disconnected Check
Fuel Heater Connected Check
Sensor Check
Terminal Check
Circuit Check
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
ECU Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
000174.16 – Fuel Temperature Signal Moderately High
000189.31 – Engine Speed Derate Condition Exists
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
000190.16 – Engine Speed Moderately High
Group 162 – DTC SPN – 000200—000699
000237.02 – VIN Security Data Invalid
000237.13 – VIN Option Code Security Data Conflict
000237.31 – VIN Security Data Missing
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Replace Sensor
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Replace Sensor
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
000412.15 – EGR Temperature Signal Slightly High
000412.16 – EGR Temperature Signal Moderately High
000443.00 – Auxiliary Gauge Pressure #2 Reading Extremely High
000443.01 – Auxiliary Gauge Pressure #2 Reading Extremely Low
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Unswitched Voltage Check
Switched Voltage Check
Terminal Check
DTC Check With ECU Disconnected
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Reprogram ECU
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Unswitched Voltage Check
Switched Voltage Check
Terminal Check
DTC Check With ECU Disconnected
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Reprogram ECU
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Voltage Check With Injector Harness Disconnected
Terminal Check
Voltage Check With ECU Disconnected
Reprogram ECU
Short to Ground Check
Short to Another Wire Check
Terminal Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Short to Ground Check
Circuit Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Short to Ground Check
Read DTCs and Store Snapshot Information
Terminal Check
Voltage Check With Injector Harness Disconnected
Terminal Check
Voltage Check With ECU Disconnected
Reprogram ECU
Short to Ground Check
Short to Another Wire Check
Terminal Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Short to Ground Check
Circuit Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Short to Ground Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Unswitched Voltage Check
Switched Voltage Check
Terminal Check
Voltage Check With ECU Disconnected
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Reprogram ECU
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Unswitched Voltage Check
Switched Voltage Check
Terminal Check
Voltage Check With ECU Disconnected
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Reprogram ECU
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Voltage Check With Injector Harness Disconnected
Terminal Check
Voltage Check With ECU Disconnected
Reprogram ECU
Short to Ground Check
Short to Another Wire Check
Terminal Check
Short to Another Wire Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Short to Ground Check
Circuit Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Short to Ground Check
Read DTCs and Store Snapshot Information
Terminal Check
Voltage Check With Injector Harness Disconnected
Terminal Check
Voltage Check With ECU Disconnected
Reprogram ECU
Short to Ground Check
Short to Another Wire Check
Terminal Check
Short to Another Wire Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Short to Ground Check
Circuit Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Short to Ground Check
Diagnostic Procedure
Reprogram ECU and Store Snapshot Information
Reprogram ECU
Replace ECU
Reprogram ECU and Store Snapshot Information
Reprogram ECU
Replace ECU
Diagnostic Procedure
Reprogram ECU
Replace ECU
Reprogram ECU
Replace ECU
Diagnostic Procedure
Read DTCs and Store Snapshot Information
DTC Check
Terminal Check
Continuity Check
Sensor Inspection
Physical Damage Inspection
Electrical Noise Check
Read DTCs and Store Snapshot Information
DTC Check
Terminal Check
Continuity Check
Sensor Inspection
Physical Damage Inspection
Electrical Noise Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Circuit Check
High Resistance Check
Read DTCs and Store Snapshot Information
Circuit Check
High Resistance Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Circuit Check
Terminal Check
Short to Return Wire Check
Short to Ground Check
Wire to Wire Check
Wire to Wire Short Check
Terminal Check
Terminal Check
Short to Return Wire Check
Short to Ground Check
Wire to Wire Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Circuit Check
Terminal Check
Short to Return Wire Check
Short to Ground Check
Wire to Wire Check
Wire to Wire Short Check
Terminal Check
Terminal Check
Short to Return Wire Check
Short to Ground Check
Wire to Wire Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Sensor Inspection
Short to Voltage Check
Terminal Check
Continuity Check
Short to Ground Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Sensor Inspection
Short to Voltage Check
Terminal Check
Continuity Check
Short to Ground Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Check for Loose Sensor
Sensor Inspection
Physical Damage Inspection
Terminal Check
Continuity Check
Wire-to-Wire Short
Shorted Sensor Return
Circuit Check
Electrical Noise Check
Reprogram ECU
Reprogram ECU
Replace Camshaft Sensor
Read DTCs and Store Snapshot Information
Terminal Check
Check for Loose Sensor
Sensor Inspection
Physical Damage Inspection
Terminal Check
Continuity Check
Wire-to-Wire Short
Shorted Sensor Return
Circuit Check
Electrical Noise Check
Reprogram ECU
Reprogram ECU
Replace Camshaft Sensor
Diagnostic Procedure
Read DTCs and Store Snapshot Information
DTC Check
Terminal Check
Continuity Check
Sensor Inspection
Physical Damage Inspection
Electrical Noise Check
Read DTCs and Store Snapshot Information
DTC Check
Terminal Check
Continuity Check
Sensor Inspection
Physical Damage Inspection
Electrical Noise Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Circuit Check
High Resistance Check
Read DTCs and Store Snapshot Information
Circuit Check
High Resistance Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Circuit Check
Terminal Check
Short to Return Wire Check
Short to Ground Check
Wire to Wire Check
Wire to Wire Short Check
Terminal Check
Terminal Check
Short to Return Wire Check
Short to Ground Check
Wire to Wire Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Circuit Check
Terminal Check
Short to Return Wire Check
Short to Ground Check
Wire to Wire Check
Wire to Wire Short Check
Terminal Check
Terminal Check
Short to Return Wire Check
Short to Ground Check
Wire to Wire Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Service Check
Terminal Check
Terminal Check
Continuity Check
Continuity Check
Read DTCs and Store Snapshot Information
Service Check
Terminal Check
Terminal Check
Continuity Check
Continuity Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTC List
Terminal Check
Sensor Inspection
Short to Voltage Check
Terminal Check
Continuity Check
Short to Ground Check
Read DTCs and Store Snapshot Information
Read DTC List
Terminal Check
Sensor Inspection
Short to Voltage Check
Terminal Check
Continuity Check
Short to Ground Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Check for Loose Sensor
Sensor Inspection
Physical Damage Inspection
Terminal Check
Continuity Check
Wire-to-Wire Short
Shorted Sensor Return
Circuit Check
Electrical Noise Check
Reprogram ECU
Reprogram ECU
Replace Crankshaft Sensor
Read DTCs and Store Snapshot Information
Terminal Check
Check for Loose Sensor
Sensor Inspection
Physical Damage Inspection
Terminal Check
Continuity Check
Wire-to-Wire Short
Shorted Sensor Return
Circuit Check
Electrical Noise Check
Reprogram ECU
Reprogram ECU
Replace Crankshaft Sensor
000640.11 – External Engine Protection Activated
000640.31 – External Derate Activated
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Cooling System Check
Heat Source Check
DTC Check
Read DTCs and Store Snapshot Information
Cooling System Check
Heat Source Check
DTC Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Short to Voltage Check
Continuity Check
Continuity Check
Terminal Check
Terminal Check
Continuity Check
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Short to Voltage Check
Continuity Check
Continuity Check
Terminal Check
Terminal Check
Continuity Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Wire to Wire Check
Wire to Wire Check
ECU Check
Terminal Check
Terminal Check
Wire to Wire Check
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Wire to Wire Check
Wire to Wire Check
ECU Check
Terminal Check
Terminal Check
Wire to Wire Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Movement Check
Binding Check
Binding Check
Linkage Check
Check Codes
Read DTCs and Store Snapshot Information
Movement Check
Binding Check
Binding Check
Linkage Check
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Active Code Check
Terminal Check
Supply Voltage Check
Return Circuit Check
CAN Circuit Check
Terminal Check
Continuity Check
Harness Check
Circuit Check
Check Codes
Read DTCs and Store Snapshot Information
Active Code Check
Terminal Check
Supply Voltage Check
Return Circuit Check
CAN Circuit Check
Terminal Check
Continuity Check
Harness Check
Circuit Check
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Movement Check
Binding Check
Binding Check
Linkage Check
Read DTCs and Store Snapshot Information
Movement Check
Binding Check
Binding Check
Linkage Check
000641.16 – VGT Actuator Temperature Moderately High
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Actuator Check
Charging System Check
Terminal Check
Circuit Check
Terminal Check
Continuity Check
Check Codes
Read DTCs and Store Snapshot Information
Actuator Check
Charging System Check
Terminal Check
Circuit Check
Terminal Check
Continuity Check
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Continuity Check
Continuity Check
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Continuity Check
Continuity Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Short to Ground Check
Wire to Wire Check
Wire to Wire Check
Wire to Wire Short Check
Replace Variable Speed Fan Drive
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Short to Ground Check
Wire to Wire Check
Wire to Wire Check
Wire to Wire Short Check
Replace Variable Speed Fan Drive
000647.07 – Engine Fan Drive Decrease Circuit Has High Resistance
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Check Injector Part Number
Verify Correct Part
ECU Reprogram
Clear DTCs
Read DTCs and Store Snapshot Information
Check Injector Part Number
Verify Correct Part
ECU Reprogram
Clear DTCs
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Check Injector Part Number
Verify Correct Part
ECU Reprogram
Clear DTCs
Read DTCs and Store Snapshot Information
Check Injector Part Number
Verify Correct Part
ECU Reprogram
Clear DTCs
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Check Injector Part Number
Verify Correct Part
ECU Reprogram
Clear DTCs
Read DTCs and Store Snapshot Information
Check Injector Part Number
Verify Correct Part
ECU Reprogram
Clear DTCs
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Check Injector Part Number
Verify Correct Part
ECU Reprogram
Clear DTCs
Read DTCs and Store Snapshot Information
Check Injector Part Number
Verify Correct Part
ECU Reprogram
Clear DTCs
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Check Injector Part Number
Verify Correct Part
ECU Reprogram
Clear DTCs
Read DTCs and Store Snapshot Information
Check Injector Part Number
Verify Correct Part
ECU Reprogram
Clear DTCs
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Check Injector Part Number
Verify Correct Part
ECU Reprogram
Clear DTCs
Read DTCs and Store Snapshot Information
Check Injector Part Number
Verify Correct Part
ECU Reprogram
Clear DTCs
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
000695.19 – Unapproved Engine Speed Request
Group 163 – DTC SPN – 000700—001999
000876.05 – A/C System Drive Circuit Has High Resistance
000876.06 – A/C System Drive Circuit Has Low Resistance
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Check Condition That Set Switch
Terminal Check
Terminal Check
Open Circuit Check
Short to Ground Check
Wire to Wire Short Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Check Condition That Set Switch
Terminal Check
Terminal Check
Open Circuit Check
Short to Ground Check
Wire to Wire Short Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Check Condition That Set Switch
Terminal Check
Terminal Check
Open Circuit Check
Short to Ground Check
Wire to Wire Short Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Check Condition That Set Switch
Terminal Check
Terminal Check
Open Circuit Check
Short to Ground Check
Wire to Wire Short Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
001069.31 – Calculated Tire Size Is Out Of Range
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Supply Voltage Check
Return Circuit Check
CAN Circuit Check
Terminal Check
Continuity Check
Harness Check
Circuit Check
Read DTCs and Store Snapshot Information
Terminal Check
Supply Voltage Check
Return Circuit Check
CAN Circuit Check
Terminal Check
Continuity Check
Harness Check
Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Supply Voltage Check
Return Circuit Check
Read DTCs and Store Snapshot Information
Terminal Check
Supply Voltage Check
Return Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Air Bleed Check
Terminal Check
Supply Voltage Check
Return Circuit Check
Fuel Return Line Restriction Test
Read DTCs and Store Snapshot Information
Air Bleed Check
Terminal Check
Supply Voltage Check
Return Circuit Check
Fuel Return Line Restriction Test
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Active Code Check
Terminal Check
Supply Voltage Check
Return Circuit Check
Pump Enable Check
Terminal Check
Short to Ground Check
Continuity Check
Short Check
CAN Circuit Check
Terminal Check
Continuity Check
Harness Check
Circuit Check
Read DTCs and Store Snapshot Information
Active Code Check
Terminal Check
Supply Voltage Check
Return Circuit Check
Pump Enable Check
Terminal Check
Short to Ground Check
Continuity Check
Short Check
CAN Circuit Check
Terminal Check
Continuity Check
Harness Check
Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Active Code Check
Terminal Check
Supply Voltage Check
Return Circuit Check
Pump Enable Check
Terminal Check
Short to Ground Check
Continuity Check
Short Check
CAN Circuit Check
Terminal Check
Continuity Check
Harness Check
Circuit Check
Read DTCs and Store Snapshot Information
Active Code Check
Terminal Check
Supply Voltage Check
Return Circuit Check
Pump Enable Check
Terminal Check
Short to Ground Check
Continuity Check
Short Check
CAN Circuit Check
Terminal Check
Continuity Check
Harness Check
Circuit Check
001075.15 – Low-Pressure Fuel Pump Temperature Slightly High
001110.31 – Engine Protection System Activated
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Check Physical Environment
Test ECU
Test ECU
Verification
Review Snapshot Information
Read DTCs and Store Snapshot Information
Check Physical Environment
Test ECU
Test ECU
Verification
Review Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
001136.16 – ECU Temperature Signal Moderately High
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Manifold Air Pressure Check
Check for Exhaust Restriction
Check for Charge Air Leaks
Charge Air Cooler Check
Perform High-Pressure Fuel System Check
Reprogram ECU
Check Codes
Read DTCs and Store Snapshot Information
Manifold Air Pressure Check
Check for Exhaust Restriction
Check for Charge Air Leaks
Charge Air Cooler Check
Perform High-Pressure Fuel System Check
Reprogram ECU
Check Codes
001180.16 – Calculated VGT Turbine Inlet Temperature Moderately High
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Snapshot Information
Leak Check
Terminal Check
Supply Circuit Check
Circuit Check
Signal Circuit Check
Software Check
EGR Cooler Check
Reprogram ECU
Terminal Check
Continuity Check
Read DTCs and Store Snapshot Information
Code Check
Snapshot Information
Leak Check
Terminal Check
Supply Circuit Check
Circuit Check
Signal Circuit Check
Software Check
EGR Cooler Check
Reprogram ECU
Terminal Check
Continuity Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Short to Voltage Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Terminal Check
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Short to Voltage Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Terminal Check
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Wire to Wire Check
Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Wire to Wire Check
Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Load Test Batteries
Check Starter Solenoid Control Circuit
Check Starter Cables
ECU Reprogram
Read DTCs and Store Snapshot Information
Load Test Batteries
Check Starter Solenoid Control Circuit
Check Starter Cables
ECU Reprogram
001550.05 – Air Conditioner Compressor Current Low
001550.06 – Air Conditioner Compressor Current High
001569.31 – Engine Power Derate Condition Exists
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Preliminary Checks
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Continuity Check
Read DTCs and Store Snapshot Information
Preliminary Checks
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Continuity Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Preliminary Checks
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Continuity Check
Read DTCs and Store Snapshot Information
Preliminary Checks
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Continuity Check
001639.18 – Fan Speed Signal Moderately Low
001761.01 – DEF Tank Fluid Level Signal Extremely Low
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
DEF Tank Refill
DEF Tank Header Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
DEF Tank Header Inspection
Read DTCs and Store Snapshot Information
Code Check
Code Check
DEF Tank Refill
DEF Tank Header Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
DEF Tank Header Inspection
001761.18 – DEF Tank Fluid Level Signal Moderately Low
Group 164 – DTC SPN – 002000—002299
002002.09 – No CAN Message Received From Source Address 2
002003.09 – No CAN Message Received From Source Address 3
002003.14 – Incorrect CAN Message Received From Source Address 3
002003.19 – Communication Error with Source Address 3
002004.09 – No CAN Message Received From Source Address 4
002005.09 – No CAN Message Received From Source Address 5
002006.09 – No CAN Message Received From Source Address 6
002006.14 – Incorrect CAN Message Received From Source Address 6
002006.19 – Communication Error with Source Address 6
002007.09 – No CAN Message Received From Source Address 7
002008.09 – No CAN Message Received From Source Address 8
002009.09 – No CAN Message Received From Source Address 9
002010.09 – No CAN Message Received From Source Address 10
002011.09 – No CAN Message Received From Source Address 11
002012.09 – No CAN Message Received From Source Address 12
002013.09 – No CAN Message Received From Source Address 13
002014.09 – No CAN Message Received From Source Address 14
002015.09 – No CAN Message Received From Source Address 15
002016.09 – No CAN Message Received From Source Address 16
002017.09 – No CAN Message Received From Source Address 17
002018.09 – No CAN Message Received From Source Address 18
002019.09 – No CAN Message Received From Source Address 19
002020.09 – No CAN Message Received From Source Address 20
002021.09 – No CAN Message Received From Source Address 21
002022.09 – No CAN Message Received From Source Address 22
002023.09 – No CAN Message Received From Source Address 23
002024.09 – No CAN Message Received From Source Address 24
002025.09 – No CAN Message Received From Source Address 25
002025.14 – Incorrect CAN Message Received From Source Address 25
002025.19 – Communication Error with Source Address 25
002026.09 – No CAN Message Received From Source Address 26
002027.09 – No CAN Message Received From Source Address 27
002028.09 – No CAN Message Received From Source Address 28
002029.09 – No CAN Message Received From Source Address 29
002030.09 – No CAN Message Received From Source Address 30
002030.14 – Incorrect CAN Message Received From Source Address 30
002030.19 – Communication Error with Source Address 30
002031.09 – No CAN Message Received From Source Address 31
002032.09 – No CAN Message Received From Source Address 32
002033.09 – No CAN Message Received From Source Address 33
002033.14 – Incorrect CAN Message Received From Source Address 33
002033.19 – Communication Error with Source Address 33
002034.09 – No CAN Message Received From Source Address 34
002035.09 – No CAN Message Received From Source Address 35
002036.09 – No CAN Message Received From Source Address 36
002037.09 – No CAN Message Received From Source Address 37
002038.09 – No CAN Message Received From Source Address 38
002039.09 – No CAN Message Received From Source Address 39
002040.09 – No CAN Message Received From Source Address 40
002040.14 – Incorrect CAN Message Received From Source Address 40
002040.19 – Communication Error with Source Address 40
002041.09 – No CAN Message Received From Source Address 41
002042.09 – No CAN Message Received From Source Address 42
002043.09 – No CAN Message Received From Source Address 43
002044.09 – No CAN Message Received From Source Address 44
002045.09 – No CAN Message Received From Source Address 45
002046.09 – No CAN Message Received From Source Address 46
002047.09 – No CAN Message Received From Source Address 47
002048.09 – No CAN Message Received From Source Address 48
002049.09 – No CAN Message Received From Source Address 49
002049.14 – Incorrect CAN Message Received From Source Address 49
002049.19 – Communication Error with Source Address 49
002050.09 – No CAN Message Received From Source Address 50
002051.09 – No CAN Message Received From Source Address 51
002052.09 – No CAN Message Received From Source Address 52
002053.09 – No CAN Message Received From Source Address 53
002054.09 – No CAN Message Received From Source Address 54
002055.09 – No CAN Message Received From Source Address 55
002056.09 – No CAN Message Received From Source Address 56
002057.09 – No CAN Message Received From Source Address 57
002058.09 – No CAN Message Received From Source Address 58
002059.09 – No CAN Message Received From Source Address 59
002060.09 – No CAN Message Received From Source Address 60
002061.09 – No CAN Message Received From Source Address 61
002062.09 – No CAN Message Received From Source Address 62
002063.09 – No CAN Message Received From Source Address 63
002064.09 – No CAN Message Received From Source Address 64
002065.09 – No CAN Message Received From Source Address 65
002066.09 – No CAN Message Received From Source Address 66
002067.09 – No CAN Message Received From Source Address 67
002068.09 – No CAN Message Received From Source Address 68
002069.09 – No CAN Message Received From Source Address 69
002070.09 – No CAN Message Received From Source Address 70
002071.09 – No CAN Message Received From Source Address 71
002071.14 – Incorrect CAN Message Received From Source Address 71
002071.19 – Communication Error with Source Address 71
002072.09 – No CAN Message Received From Source Address 72
002073.09 – No CAN Message Received From Source Address 73
002074.09 – No CAN Message Received From Source Address 74
002075.09 – No CAN Message Received From Source Address 75
002076.09 – No CAN Message Received From Source Address 76
002077.09 – No CAN Message Received From Source Address 77
002078.09 – No CAN Message Received From Source Address 78
002079.09 – No CAN Message Received From Source Address 79
002080.09 – No CAN Message Received From Source Address 80
002081.09 – No CAN Message Received From Source Address 81
002082.09 – No CAN Message Received From Source Address 82
002083.09 – No CAN Message Received From Source Address 83
002084.09 – No CAN Message Received From Source Address 84
002085.09 – No CAN Message Received From Source Address 85
002086.09 – No CAN Message Received From Source Address 86
002087.09 – No CAN Message Received From Source Address 87
002088.09 – No CAN Message Received From Source Address 88
002089.09 – No CAN Message Received From Source Address 89
002090.09 – No CAN Message Received From Source Address 90
002091.09 – No CAN Message Received From Source Address 91
002092.09 – No CAN Message Received From Source Address 92
002093.09 – No CAN Message Received From Source Address 93
002094.09 – No CAN Message Received From Source Address 94
002095.09 – No CAN Message Received From Source Address 95
002096.09 – No CAN Message Received From Source Address 96
002097.09 – No CAN Message Received From Source Address 97
002098.09 – No CAN Message Received From Source Address 98
002099.09 – No CAN Message Received From Source Address 99
002100.09 – No CAN Message Received From Source Address 100
002101.09 – No CAN Message Received From Source Address 101
002102.09 – No CAN Message Received From Source Address 102
002103.09 – No CAN Message Received From Source Address 103
002104.09 – No CAN Message Received From Source Address 104
002105.09 – No CAN Message Received From Source Address 105
002106.09 – No CAN Message Received From Source Address 106
002107.09 – No CAN Message Received From Source Address 107
002108.09 – No CAN Message Received From Source Address 108
002109.09 – No CAN Message Received From Source Address 109
002110.09 – No CAN Message Received From Source Address 110
002111.09 – No CAN Message Received From Source Address 111
002112.09 – No CAN Message Received From Source Address 112
002113.09 – No CAN Message Received From Source Address 113
002114.09 – No CAN Message Received From Source Address 114
002115.09 – No CAN Message Received From Source Address 115
002116.09 – No CAN Message Received From Source Address 116
002117.09 – No CAN Message Received From Source Address 117
002118.09 – No CAN Message Received From Source Address 118
002119.09 – No CAN Message Received From Source Address 119
002120.09 – No CAN Message Received From Source Address 120
002121.09 – No CAN Message Received From Source Address 121
002122.09 – No CAN Message Received From Source Address 122
002123.09 – No CAN Message Received From Source Address 123
002124.09 – No CAN Message Received From Source Address 124
002125.09 – No CAN Message Received From Source Address 125
002126.09 – No CAN Message Received From Source Address 126
002127.09 – No CAN Message Received From Source Address 127
002128.09 – No CAN Message Received From Source Address 128
002129.09 – No CAN Message Received From Source Address 129
002130.09 – No CAN Message Received From Source Address 130
002131.09 – No CAN Message Received From Source Address 131
002132.09 – No CAN Message Received From Source Address 132
002133.09 – No CAN Message Received From Source Address 133
002134.09 – No CAN Message Received From Source Address 134
002135.09 – No CAN Message Received From Source Address 135
002136.09 – No CAN Message Received From Source Address 136
002137.09 – No CAN Message Received From Source Address 137
002138.09 – No CAN Message Received From Source Address 138
002139.09 – No CAN Message Received From Source Address 139
002140.09 – No CAN Message Received From Source Address 140
002141.09 – No CAN Message Received From Source Address 141
002142.09 – No CAN Message Received From Source Address 142
002143.09 – No CAN Message Received From Source Address 143
002144.09 – No CAN Message Received From Source Address 144
002145.09 – No CAN Message Received From Source Address 145
002146.09 – No CAN Message Received From Source Address 146
002147.09 – No CAN Message Received From Source Address 147
002148.09 – No CAN Message Received From Source Address 148
002149.09 – No CAN Message Received From Source Address 149
002150.09 – No CAN Message Received From Source Address 150
002151.09 – No CAN Message Received From Source Address 151
002152.09 – No CAN Message Received From Source Address 152
002153.09 – No CAN Message Received From Source Address 153
002154.09 – No CAN Message Received From Source Address 154
002155.09 – No CAN Message Received From Source Address 155
002156.09 – No CAN Message Received From Source Address 156
002157.09 – No CAN Message Received From Source Address 157
002158.09 – No CAN Message Received From Source Address 158
002159.09 – No CAN Message Received From Source Address 159
002160.09 – No CAN Message Received From Source Address 160
002161.09 – No CAN Message Received From Source Address 161
002162.09 – No CAN Message Received From Source Address 162
002163.09 – No CAN Message Received From Source Address 163
002164.09 – No CAN Message Received From Source Address 164
002165.09 – No CAN Message Received From Source Address 165
002166.09 – No CAN Message Received From Source Address 166
002167.09 – No CAN Message Received From Source Address 167
002168.09 – No CAN Message Received From Source Address 168
002169.09 – No CAN Message Received From Source Address 169
002170.09 – No CAN Message Received From Source Address 170
002171.09 – No CAN Message Received From Source Address 171
002172.09 – No CAN Message Received From Source Address 172
002173.09 – No CAN Message Received From Source Address 173
002174.09 – No CAN Message Received From Source Address 174
002175.09 – No CAN Message Received From Source Address 175
002176.09 – No CAN Message Received From Source Address 176
002177.09 – No CAN Message Received From Source Address 177
002178.09 – No CAN Message Received From Source Address 178
002179.09 – No CAN Message Received From Source Address 179
002180.09 – No CAN Message Received From Source Address 180
002181.09 – No CAN Message Received From Source Address 181
002182.09 – No CAN Message Received From Source Address 182
002183.09 – No CAN Message Received From Source Address 183
002184.09 – No CAN Message Received From Source Address 184
002185.09 – No CAN Message Received From Source Address 185
002186.09 – No CAN Message Received From Source Address 186
002187.09 – No CAN Message Received From Source Address 187
002188.09 – No CAN Message Received From Source Address 188
002189.09 – No CAN Message Received From Source Address 189
002190.09 – No CAN Message Received From Source Address 190
002191.09 – No CAN Message Received From Source Address 191
002192.09 – No CAN Message Received From Source Address 192
002193.09 – No CAN Message Received From Source Address 193
002194.09 – No CAN Message Received From Source Address 194
002195.09 – No CAN Message Received From Source Address 195
002196.09 – No CAN Message Received From Source Address 196
002197.09 – No CAN Message Received From Source Address 197
002198.09 – No CAN Message Received From Source Address 198
002199.09 – No CAN Message Received From Source Address 199
002200.09 – No CAN Message Received From Source Address 200
002201.09 – No CAN Message Received From Source Address 201
002202.09 – No CAN Message Received From Source Address 202
002203.09 – No CAN Message Received From Source Address 203
002204.09 – No CAN Message Received From Source Address 204
002205.09 – No CAN Message Received From Source Address 205
002206.09 – No CAN Message Received From Source Address 206
002207.09 – No CAN Message Received From Source Address 207
002208.09 – No CAN Message Received From Source Address 208
002209.09 – No CAN Message Received From Source Address 209
002210.09 – No CAN Message Received From Source Address 210
002211.09 – No CAN Message Received From Source Address 211
002212.09 – No CAN Message Received From Source Address 212
002213.09 – No CAN Message Received From Source Address 213
002214.09 – No CAN Message Received From Source Address 214
002215.09 – No CAN Message Received From Source Address 215
002216.09 – No CAN Message Received From Source Address 216
002217.09 – No CAN Message Received From Source Address 217
002218.09 – No CAN Message Received From Source Address 218
002219.09 – No CAN Message Received From Source Address 219
002220.09 – No CAN Message Received From Source Address 220
002221.09 – No CAN Message Received From Source Address 221
002222.09 – No CAN Message Received From Source Address 222
002223.09 – No CAN Message Received From Source Address 223
002224.09 – No CAN Message Received From Source Address 224
002225.09 – No CAN Message Received From Source Address 225
002226.09 – No CAN Message Received From Source Address 226
002227.09 – No CAN Message Received From Source Address 227
002228.09 – No CAN Message Received From Source Address 228
002228.14 – Incorrect CAN Message Received From Source Address 228
002228.19 – Communication Error with Source Address 228
002229.09 – No CAN Message Received From Source Address 229
002230.09 – No CAN Message Received From Source Address 230
002231.09 – No CAN Message Received From Source Address 231
002232.09 – No CAN Message Received From Source Address 232
002233.09 – No CAN Message Received From Source Address 233
002234.09 – No CAN Message Received From Source Address 234
002235.09 – No CAN Message Received From Source Address 235
002236.09 – No CAN Message Received From Source Address 236
002237.09 – No CAN Message Received From Source Address 237
002238.09 – No CAN Message Received From Source Address 238
002239.09 – No CAN Message Received From Source Address 239
002240.09 – No CAN Message Received From Source Address 240
002241.09 – No CAN Message Received From Source Address 241
002242.09 – No CAN Message Received From Source Address 242
002243.09 – No CAN Message Received From Source Address 243
002244.09 – No CAN Message Received From Source Address 244
002245.09 – No CAN Message Received From Source Address 245
002246.09 – No CAN Message Received From Source Address 246
002247.09 – No CAN Message Received From Source Address 247
002248.09 – No CAN Message Received From Source Address 248
002249.09 – No CAN Message Received From Source Address 249
002250.09 – No CAN Message Received From Source Address 250
002251.09 – No CAN Message Received From Source Address 251
002252.09 – No CAN Message Received From Source Address 252
002253.09 – No CAN Message Received From Source Address 253
Group 165 – DTC SPN – 002300—002999
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Replace Sensor
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Replace Sensor
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
002630.15 – Charge Air Cooler Outlet Temperature Signal Slightly High
002630.16 – Charge Air Cooler Outlet Temperature Signal Moderately High
Diagnostic Procedure
Read DTCs and Store Snapshot Information
EGR Leak Check
Check EGR Flow Sensor
Terminal Check
Supply Circuit Check
Open or High Resistance Check
Signal Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Check Codes
Read DTCs and Store Snapshot Information
EGR Leak Check
Check EGR Flow Sensor
Terminal Check
Supply Circuit Check
Open or High Resistance Check
Signal Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Check Codes
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Check Codes
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Reprogram ECU
Review Stored Snapshot Information
Read DTCs and Store Snapshot Information
Reprogram ECU
Review Stored Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Supply Circuit Check
Open or High Resistance Check
Signal Circuit Check
Terminal Check
Continuity Check
Check EGR Valve
Software Check
Reprogram ECU
Check Codes
Read DTCs and Store Snapshot Information
Terminal Check
Supply Circuit Check
Open or High Resistance Check
Signal Circuit Check
Terminal Check
Continuity Check
Check EGR Valve
Software Check
Reprogram ECU
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Supply Circuit Check
Open or High Resistance Check
Signal Circuit Check
Terminal Check
Continuity Check
Software Check
Sensor Inputs Check
Check EGR Valve
Reprogram ECU
Read DTCs and Store Snapshot Information
Terminal Check
Supply Circuit Check
Open or High Resistance Check
Signal Circuit Check
Terminal Check
Continuity Check
Software Check
Sensor Inputs Check
Check EGR Valve
Reprogram ECU
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Monitor Sensors
Terminal Check
Circuit Check
Circuit Check
Software Check
Preliminary Checks
Recreate Problem Conditions
More Items That Can Cause Problem
Monitor Sensors
Reprogram ECU
Read DTCs and Store Snapshot Information
Monitor Sensors
Terminal Check
Circuit Check
Circuit Check
Software Check
Preliminary Checks
Recreate Problem Conditions
More Items That Can Cause Problem
Monitor Sensors
Reprogram ECU
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Short to Voltage Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Replace EGR Valve
Terminal Check
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Short to Voltage Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Replace EGR Valve
Terminal Check
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Wire to Wire Check
Replace EGR Valve
Terminal Check
Terminal Check
Wire to Wire Check
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Wire to Wire Check
Replace EGR Valve
Terminal Check
Terminal Check
Wire to Wire Check
Diagnostic Procedure
Store Snapshot Information and Terminal Check
Supply Circuit Check
Signal Circuit Check
Software Check
Clean EGR Valve
Circuit Check
Reprogram ECU
Terminal Check
Continuity Check
Check Codes
Store Snapshot Information and Terminal Check
Supply Circuit Check
Signal Circuit Check
Software Check
Clean EGR Valve
Circuit Check
Reprogram ECU
Terminal Check
Continuity Check
Check Codes
Diagnostic Procedure
Store Snapshot Information and Terminal Check
Clean EGR Valve
Store Snapshot Information and Terminal Check
Clean EGR Valve
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Binding Check
Binding Check
Linkage Check
Check Codes
Read DTCs and Store Snapshot Information
Binding Check
Binding Check
Linkage Check
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Binding Check
Binding Check
Linkage Check
Read DTCs and Store Snapshot Information
Binding Check
Binding Check
Linkage Check
Group 166 – DTC SPN – 003000—003999
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Supply Voltage Check
Return Circuit Check
CAN Circuit Check
Associated Components Check
Terminal Check
Continuity Check
Harness Check
Circuit Check
Read DTCs and Store Snapshot Information
Terminal Check
Supply Voltage Check
Return Circuit Check
CAN Circuit Check
Associated Components Check
Terminal Check
Continuity Check
Harness Check
Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Preliminary Checks
Code Check
Code Check
Preliminary Checks
Code Check
Code Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Supply Voltage Check
Return Circuit Check
CAN Circuit Check
Associated Component Check
Terminal Check
Continuity Check
Harness Check
Circuit Check
Read DTCs and Store Snapshot Information
Terminal Check
Supply Voltage Check
Return Circuit Check
CAN Circuit Check
Associated Component Check
Terminal Check
Continuity Check
Harness Check
Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Preliminary Checks
Code Check
Code Check
Preliminary Checks
Code Check
Code Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Temperature Comparison
Temperature Comparison
Read DTCs and Store Snapshot Information
Temperature Comparison
Temperature Comparison
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Supply Circuit Check
Circuit Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Verify Problem
Read DTCs and Store Snapshot Information
Terminal Check
Supply Circuit Check
Circuit Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Verify Problem
003251.02 – DPF Differential Pressure Signal Invalid
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Code Check
Terminal Check
Supply Circuit Check
Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Code Check
Code Check
Terminal Check
Supply Circuit Check
Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
003251.07 – DPF Differential Pressure Signal Mismatch
003353.31 – Alternator Excitation Condition Exists
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Check
Terminal Check
ECU Check
Circuit Check
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Check
Terminal Check
ECU Check
Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Check.
Terminal Check
ECU Check
Continuity Check
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Check.
Terminal Check
ECU Check
Continuity Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
DEF Dosing Injector Check
Terminal Check
Continuity Check
DEF Dosing System Check
Read DTCs and Store Snapshot Information
Terminal Check
DEF Dosing Injector Check
Terminal Check
Continuity Check
DEF Dosing System Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
DEF Dosing Injector Check
Terminal Check
Continuity Check
Continuity Check
DEF Dosing System Check
Read DTCs and Store Snapshot Information
Terminal Check
DEF Dosing Injector Check
Terminal Check
Continuity Check
Continuity Check
DEF Dosing System Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
DEF Quality Test
DEF Dosing System Check
Engine Warm-up
DEF Dosing System Check
Test Results
DEF Dosing Injector Check
DEF Injector Replacement
Test Result
Code Check
DEF Dosing System Check
Read DTCs and Store Snapshot Information
DEF Quality Test
DEF Dosing System Check
Engine Warm-up
DEF Dosing System Check
Test Results
DEF Dosing Injector Check
DEF Injector Replacement
Test Result
Code Check
DEF Dosing System Check
Diagnostic Procedure
Preliminary Checks
Read DTCs and Store Snapshot Information
DEF Dosing System Check
DEF Dosing System Check
Engine Warm-up
Code Check
Pressure Line Check
Injector Wires Check
Terminal Check
Terminal Check
Continuity Check
DEF Injector Check
DEF Quantity Check
DEF Dosing System Check
Test Results
Test Results
Engine Warm-up
Preliminary Checks
Read DTCs and Store Snapshot Information
DEF Dosing System Check
DEF Dosing System Check
Engine Warm-up
Code Check
Pressure Line Check
Injector Wires Check
Terminal Check
Terminal Check
Continuity Check
DEF Injector Check
DEF Quantity Check
DEF Dosing System Check
Test Results
Test Results
Engine Warm-up
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Short to Voltage Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Replace Air Throttle Actuator
Terminal Check
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Short to Voltage Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Replace Air Throttle Actuator
Terminal Check
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Wire to Wire Check
Replace Air Throttle Actuator
Terminal Check
Terminal Check
Wire to Wire Check
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Wire to Wire Check
Replace Air Throttle Actuator
Terminal Check
Terminal Check
Wire to Wire Check
Diagnostic Procedure
Store Snapshot Information and Terminal Check
Supply Circuit Check
Signal Circuit Check
Software Check
Clean Air Throttle Actuator
Circuit Check
Reprogram ECU
Terminal Check
Continuity Check
Check Codes
Store Snapshot Information and Terminal Check
Supply Circuit Check
Signal Circuit Check
Software Check
Clean Air Throttle Actuator
Circuit Check
Reprogram ECU
Terminal Check
Continuity Check
Check Codes
Diagnostic Procedure
Store Snapshot Information and Terminal Check
Clean Air Throttle Actuator
Store Snapshot Information and Terminal Check
Clean Air Throttle Actuator
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Circuit Check
Terminal Check
Short to Drive (-) Circuit Check
Terminal Check
Short to Drive (+) Circuit Check
Read DTCs and Store Snapshot Information
Circuit Check
Terminal Check
Short to Drive (-) Circuit Check
Terminal Check
Short to Drive (+) Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Circuit Check
Terminal Check
Short to Drive (-) Circuit Check
Terminal Check
Short to Drive (+) Circuit Check
Control Valve Short Check
Terminal Check
Short to Ground Check
Read DTCs and Store Snapshot Information
Circuit Check
Terminal Check
Short to Drive (-) Circuit Check
Terminal Check
Short to Drive (+) Circuit Check
Control Valve Short Check
Terminal Check
Short to Ground Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Open Circuit Check
Short Circuit Check
Read DTCs and Store Snapshot Information
Terminal Check
Open Circuit Check
Short Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Fuel Dosing Line Inspection
Read DTCs and Store Snapshot Information
Fuel Dosing Line Inspection
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Open Circuit Check
Short Circuit Check
Verification
ECU Replacement
Read DTCs and Store Snapshot Information
Terminal Check
Open Circuit Check
Short Circuit Check
Verification
ECU Replacement
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Fuel Filter Check
Mechanical Pressure Check
Pump Pressure Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Ground Circuit Check
Terminal Check
Signal Circuit Continuity Check
Wire to Wire Short Check
Wire to Wire Short Check
Software Check
Reprogram ECU
Read DTCs and Store Snapshot Information
Fuel Filter Check
Mechanical Pressure Check
Pump Pressure Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Ground Circuit Check
Terminal Check
Signal Circuit Continuity Check
Wire to Wire Short Check
Wire to Wire Short Check
Software Check
Reprogram ECU
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
003480.07 – Fuel Dosing Inlet Sensor Desired and Actual Pressure Mismatch
003480.18 – Fuel Dosing Inlet Pressure Signal Moderately Low
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Circuit Check
Terminal Check
Short to Drive (-) Circuit Check
Terminal Check
Short to Drive (+) Circuit Check
Read DTCs and Store Snapshot Information
Circuit Check
Terminal Check
Short to Drive (-) Circuit Check
Terminal Check
Short to Drive (+) Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Circuit Check
Terminal Check
Short to Drive (-) Circuit Check
Terminal Check
Short to Drive (+) Circuit Check
Control Valve Short Check
Terminal Check
Short to Ground Check
Read DTCs and Store Snapshot Information
Circuit Check
Terminal Check
Short to Drive (-) Circuit Check
Terminal Check
Short to Drive (+) Circuit Check
Control Valve Short Check
Terminal Check
Short to Ground Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Open Circuit Check
Short Circuit Check
Read DTCs and Store Snapshot Information
Terminal Check
Open Circuit Check
Short Circuit Check
003482.16 – Fuel Dosing Shutoff Valve Stuck Open
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Short To Voltage Check
Wire to Wire Check
Signal Wire Voltage Check
Supply Wire Voltage Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Short To Voltage Check
Wire to Wire Check
Signal Wire Voltage Check
Supply Wire Voltage Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Disconnected Component Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Supply Circuit Short to Ground Check
Component Reconnected Test
Terminal Check
Supply Wire Short To Ground Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Disconnected Component Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Supply Circuit Short to Ground Check
Component Reconnected Test
Terminal Check
Supply Wire Short To Ground Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Short To Voltage Check
Wire to Wire Check
Signal Wire Voltage Check
Supply Wire Voltage Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Short To Voltage Check
Wire to Wire Check
Signal Wire Voltage Check
Supply Wire Voltage Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Disconnected Component Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Supply Circuit Short to Ground Check
Component Reconnected Test
Terminal Check
Supply Wire Short To Ground Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Disconnected Component Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Supply Circuit Short to Ground Check
Component Reconnected Test
Terminal Check
Supply Wire Short To Ground Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Code Check
Terminal Check
ECU Disconnected Code Check
Short To Voltage Check
Wire to Wire Check
Component Reconnected Test
Signal Wire Voltage Check
Terminal Check
Continuity Check
Supply Wire Voltage Check
Continuity Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Code Check
Terminal Check
ECU Disconnected Code Check
Short To Voltage Check
Wire to Wire Check
Component Reconnected Test
Signal Wire Voltage Check
Terminal Check
Continuity Check
Supply Wire Voltage Check
Continuity Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Disconnected Component Code Check
Terminal Check
ECU Disconnected Code Check
Supply Circuit Short to Ground Check
Component Reconnected Test
Terminal Check
Supply Wire Short To Ground Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Disconnected Component Code Check
Terminal Check
ECU Disconnected Code Check
Supply Circuit Short to Ground Check
Component Reconnected Test
Terminal Check
Supply Wire Short To Ground Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short To Voltage Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
Terminal Check
Short To Voltage Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Short to Ground Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Short to Ground Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short To Voltage Check
Throttle Short to Voltage Check
Next Associated
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
Terminal Check
Short To Voltage Check
Throttle Short to Voltage Check
Next Associated
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Active Code Check
Next Associated Sensor Check
Terminal Check
Active Code Check
Terminal Check
Supply Circuit Short to Ground Check
Component Reconnected Test
Terminal Check
Supply Wire Short To Ground Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Active Code Check
Next Associated Sensor Check
Terminal Check
Active Code Check
Terminal Check
Supply Circuit Short to Ground Check
Component Reconnected Test
Terminal Check
Supply Wire Short To Ground Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Short To Voltage Check
Wire to Wire Check
Component Reconnected Test
Signal Wire Voltage Check
Terminal Check
Continuity Check
Supply Wire Voltage Check
Continuity Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Short To Voltage Check
Wire to Wire Check
Component Reconnected Test
Signal Wire Voltage Check
Terminal Check
Continuity Check
Supply Wire Voltage Check
Continuity Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Disconnected Component Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Supply Circuit Short to Ground Check
Component Reconnected Test
Terminal Check
Supply Wire Short To Ground Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Disconnected Component Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Supply Circuit Short to Ground Check
Component Reconnected Test
Terminal Check
Supply Wire Short To Ground Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Verify Problem
Verify Problem
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Fuel Dosing Outlet Pressure Check
Pressure Check With Fuel Dosing Injector Fuel Supply Line Loosened
Terminal Check
Terminal Check
Continuity Check
Short to Voltage Check
Signal Circuit Check
Software Check
Reprogram ECU
Check Codes
Read DTCs and Store Snapshot Information
Fuel Dosing Outlet Pressure Check
Pressure Check With Fuel Dosing Injector Fuel Supply Line Loosened
Terminal Check
Terminal Check
Continuity Check
Short to Voltage Check
Signal Circuit Check
Software Check
Reprogram ECU
Check Codes
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Continuity Check
Continuity Check
Terminal Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Continuity Check
Continuity Check
Terminal Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Wire to Wire Check
Terminal Check
Terminal Check
Wire to Wire Check
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Wire to Wire Check
Terminal Check
Terminal Check
Wire to Wire Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Reprogram ECU
Read DTCs and Store Snapshot Information
Reprogram ECU
003597.03 – Injector Needle Control Valve High Voltage Supply Stuck On
003597.05 – Injector Needle Control Valve Hold Circuit Stuck Off
003597.06 – Injector Needle Control Valve Hold Circuit Stuck On
003598.03 – Injector Spill Valve High Voltage Supply Stuck ON
003598.05 – Injector Spill Valve Hold Voltage Supply Circuit Stuck Off
003598.06 – Injector Spill Valve Hold Voltage Supply Circuit Stuck On
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Read DTCs and Store Snapshot Information
Terminal Check
Short to Ground Check
Terminal Check
Short to Ground Check
Short to Ground Check
Injector Wiring Harness Inspection
Short to Ground Check
Injector Check
Circuit Check
Terminal Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Terminal Check
Short Circuit DTC Check
Injector Harness Check
Terminal Check
Harness Open Circuit Check
Code Check
Terminal Check
Terminal Check
Harness Open Circuit Check
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
Read DTCs and Store Snapshot Information
Terminal Check
Harness Disconnected DTC Check
Terminal Check
Harness Disconnected DTC Check
Reprogram ECU
Harness Disconnected DTC Check
Harness Check
Harness Check
Terminal Check
Harness Check
Code Check
Injector Harness Check
Harness Disconnected DTC Check
Circuit Check
Harness Check
003711.14 – DOC Inlet Temperature Target Not Reached During ETM With Parasitic Loading
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Exhaust System Check
Air Throttle Actuator Check
Read DTCs and Store Snapshot Information
Exhaust System Check
Air Throttle Actuator Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Service Regeneration
Monitor Status
Service Regeneration
Switch Type Check
Diagnostic Gauge Check
Communication Check
Inhibit Switch Circuit Check
Terminal Check
Terminal Check
Continuity Check
Continuity Check
DPF Service Recovery
Service Regeneration
Monitor DTCs
Software Check
Read DTCs and Store Snapshot Information
Service Regeneration
Monitor Status
Service Regeneration
Switch Type Check
Diagnostic Gauge Check
Communication Check
Inhibit Switch Circuit Check
Terminal Check
Terminal Check
Continuity Check
Continuity Check
DPF Service Recovery
Service Regeneration
Monitor DTCs
Software Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Software Check
Check Codes
Software Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Reprogram ECU
Software Check
Read DTCs and Store Snapshot Information
Software Check
Check Codes
Software Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Reprogram ECU
Software Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Service Regeneration
Monitor DTCs
Read DTCs and Store Snapshot Information
Service Regeneration
Monitor DTCs
003719.14 – Calculated Soot Level Extremely High
003719.15 – Calculated Soot Level Slightly High
003719.16 – Calculated Soot Level Moderately High
003720.15 – Calculated Ash Level Slightly High
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Engine status
Temperature Comparison
Temperature Comparison
Engine status
Temperature Comparison
Temperature Comparison
Read DTCs and Store Snapshot Information
Engine status
Temperature Comparison
Temperature Comparison
Engine status
Temperature Comparison
Temperature Comparison
003936.15 – Calculated Unintended Combustibles In DPF Slightly High
003936.16 – Calculated Unintended Combustibles In DPF Moderately High
Group 167 – DTC SPN – 004000—529999
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Supply Circuit Check
Short to Voltage Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Supply Circuit Check
Short to Voltage Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Open Circuit Check
Terminal Check
Continuity Check
Open Circuit Check
Read DTCs and Store Snapshot Information
Supply Circuit Check
Short to Voltage Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Supply Circuit Check
Short to Voltage Check
Signal Circuit Check
Software Check
Reprogram ECU
Terminal Check
Continuity Check
Open Circuit Check
Terminal Check
Continuity Check
Open Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
DEF Dosing System Check
Pressure Check
Code Check
DEF Dosing System Check
Engine Warm-up
Code Check
Return Line Check
Test results
Code Check
Return Line Check
Return Line Fitting Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Verification
Test results
Code Check
Read DTCs and Store Snapshot Information
Code Check
DEF Dosing System Check
Pressure Check
Code Check
DEF Dosing System Check
Engine Warm-up
Code Check
Return Line Check
Test results
Code Check
Return Line Check
Return Line Fitting Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Verification
Test results
Code Check
Diagnostic Procedure
Preliminary Checks
High Flow Rate Test
DEF System Check
Code Check
Engine Warm-up
Code Check
High Flow Rate Test
Component Check
High Flow Rate Test
Terminal Check
Continuity Check
High Flow Rate Test
New DEF Dosing Unit Filter
New DEF Dosing Unit
Preliminary Checks
High Flow Rate Test
DEF System Check
Code Check
Engine Warm-up
Code Check
High Flow Rate Test
Component Check
High Flow Rate Test
Terminal Check
Continuity Check
High Flow Rate Test
New DEF Dosing Unit Filter
New DEF Dosing Unit
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Verification
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Verification
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Verification
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Verification
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
DEF Dosing System Check
DEF Dosing Outlet Pressure Check
Code Check
DEF Dosing System Check
Code Check
Code Check
DEF Dosing System Check
Engine Warm-up
Return Line Check
DEF Dosing Unit Return Fitting Check
Terminal Check
DEF Outlet Pressure Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
DEF Outlet Pressure Check
Continuity Check
Verification
Code Check
Read DTCs and Store Snapshot Information
Code Check
DEF Dosing System Check
DEF Dosing Outlet Pressure Check
Code Check
DEF Dosing System Check
Code Check
Code Check
DEF Dosing System Check
Engine Warm-up
Return Line Check
DEF Dosing Unit Return Fitting Check
Terminal Check
DEF Outlet Pressure Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
DEF Outlet Pressure Check
Continuity Check
Verification
Code Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
DEF Dosing System Check
Code Check
Engine Warm-up
Pressure Check
DEF Pump Diagnostic Check
Engine Warm-up
Return Fitting Check
Return Line Check
Return Line Check
Return Fitting Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Verification
Read DTCs and Store Snapshot Information
Code Check
DEF Dosing System Check
Code Check
Engine Warm-up
Pressure Check
DEF Pump Diagnostic Check
Engine Warm-up
Return Fitting Check
Return Line Check
Return Line Check
Return Fitting Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Verification
004334.18 – DEF Dosing Unit Pressure Moderately Low
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
DEF Dosing System Check
Code Check
Engine Warm-up
Pressure Check
DEF Dosing System Check
Engine Warm-up
Code Check
Return Fitting Check
Return Line Check
Test results
Code Check
Return Line Check
Return Fitting Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Verification
Test results
Code Check
Read DTCs and Store Snapshot Information
Code Check
DEF Dosing System Check
Code Check
Engine Warm-up
Pressure Check
DEF Dosing System Check
Engine Warm-up
Code Check
Return Fitting Check
Return Line Check
Test results
Code Check
Return Line Check
Return Fitting Check
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Verification
Test results
Code Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Replace DEF Dosing Unit Pressure Line Heater
Verification
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Replace DEF Dosing Unit Pressure Line Heater
Verification
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Pressure Line Heater Check
Terminal Check
Terminal Check
Terminal Check
Short to Ground Check
Wire to Wire Check
Replace DEF Dosing Unit Pressure Line Heater
Verification
Read DTCs and Store Snapshot Information
Pressure Line Heater Check
Terminal Check
Terminal Check
Terminal Check
Short to Ground Check
Wire to Wire Check
Replace DEF Dosing Unit Pressure Line Heater
Verification
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Replace DEF Dosing Unit Supply Line Heater
Verification
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Replace DEF Dosing Unit Supply Line Heater
Verification
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Supply Line Heater Check
Terminal Check
Terminal Check
Terminal Check
Short to Ground Check
Wire to Wire Check
Replace DEF Dosing Unit Supply Line Heater
Verification
Read DTCs and Store Snapshot Information
Supply Line Heater Check
Terminal Check
Terminal Check
Terminal Check
Short to Ground Check
Wire to Wire Check
Replace DEF Dosing Unit Supply Line Heater
Verification
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Replace DEF Dosing Unit Return Line Heater
Verification
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Replace DEF Dosing Unit Return Line Heater
Verification
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Return Line Heater Check
Terminal Check
Terminal Check
Terminal Check
Short to Ground Check
Wire to Wire Check
Replace DEF Dosing Unit Return Line Heater
Verification
Read DTCs and Store Snapshot Information
Return Line Heater Check
Terminal Check
Terminal Check
Terminal Check
Short to Ground Check
Wire to Wire Check
Replace DEF Dosing Unit Return Line Heater
Verification
004360.07 – SCR Inlet Temperature Invalid
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
EGR Pressure Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Check for Correct NOx Sensor Location
DEF Quality Test
DEF Quantity Check
DEF Injector Inspection
DEF Decomposition Tube Inspection and DEF Injector Replacement
DEF Decomposition Tube Inspection
Replace DEF and Run Performance Test
Code Check
Read DTCs and Store Snapshot Information
Code Check
EGR Pressure Check
Terminal Check
Signal Circuit Check
Open Circuit Check
Terminal Check
Continuity Check
Software Check
Reprogram ECU
Check for Correct NOx Sensor Location
DEF Quality Test
DEF Quantity Check
DEF Injector Inspection
DEF Decomposition Tube Inspection and DEF Injector Replacement
DEF Decomposition Tube Inspection
Replace DEF and Run Performance Test
Code Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Code Check
Code Check
SCR Performance Check
Code Check
Regeneration Check
DTC Check
Code Check
Code Check
SCR Performance Check
Code Check
Regeneration Check
DTC Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Terminal Check
Short to Voltage Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Replace DEF Tank Coolant Control Valve
Verification
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Terminal Check
Short to Voltage Check
Continuity Check
Short to Ground Check
Wire to Wire Check
Replace DEF Tank Coolant Control Valve
Verification
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Terminal Check
Short to Voltage Check
Short to Ground Check
Wire to Wire Check
Wire to Wire Check
Replace DEF Tank Coolant Control Valve
Verification
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Terminal Check
Short to Voltage Check
Short to Ground Check
Wire to Wire Check
Wire to Wire Check
Replace DEF Tank Coolant Control Valve
Verification
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Temperature Verification
Short to Voltage Check
Coolant Control Valve Verification
Read DTCs and Store Snapshot Information
Temperature Verification
Short to Voltage Check
Coolant Control Valve Verification
Diagnostic Procedure
Preliminary Checks
Read DTCs and Store Snapshot Information
DEF Tank Temperature Check
DEF Coolant Control Valve Check
Coolant Concentration and Coolant Lines Restrictions Check
Engine Coolant Temperature Check
DEF Tank Temperature Check
Terminal Check
Circuit Check
Software Check
Circuit Check
Preliminary Checks
Read DTCs and Store Snapshot Information
DEF Tank Temperature Check
DEF Coolant Control Valve Check
Coolant Concentration and Coolant Lines Restrictions Check
Engine Coolant Temperature Check
DEF Tank Temperature Check
Terminal Check
Circuit Check
Software Check
Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Wire to Wire Check
Wire to Wire Check
Replace DEF Supply Module
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Wire to Wire Check
Wire to Wire Check
Replace DEF Supply Module
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Wire to Wire Check
Wire to Wire Check
Replace DEF Supply Module
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Wire to Wire Check
Wire to Wire Check
Replace DEF Supply Module
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
DEF Dosing System Check
Test results
Engine Warm-up
Test results
Code Check
DEF Dosing System Check
Code Check
Test results
Code Check
Engine Warm-up
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
DEF Dosing System Check
Engine Warm-up
Code Check
Test results
Code Check
Read DTCs and Store Snapshot Information
Code Check
DEF Dosing System Check
Test results
Engine Warm-up
Test results
Code Check
DEF Dosing System Check
Code Check
Test results
Code Check
Engine Warm-up
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
DEF Dosing System Check
Engine Warm-up
Code Check
Test results
Code Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Temperature Modules Check
Check for active DTCs
Inspect Aftertreatment Temperature Module
Check Aftertreatment Temperature Module
Check for active DTCs
Inspect Aftertreatment Temperature Module
Check Aftertreatment Temperature Module
Read DTCs and Store Snapshot Information
Temperature Modules Check
Check for active DTCs
Inspect Aftertreatment Temperature Module
Check Aftertreatment Temperature Module
Check for active DTCs
Inspect Aftertreatment Temperature Module
Check Aftertreatment Temperature Module
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
004766.15 – DOC Outlet Temperature Slightly High
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Engine status
Temperature Comparison
Temperature Comparison
Engine status
Temperature Comparison
Temperature Comparison
Read DTCs and Store Snapshot Information
Engine status
Temperature Comparison
Temperature Comparison
Engine status
Temperature Comparison
Temperature Comparison
004766.17 – DOC Outlet Temperature Slightly Low
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Engine status
Temperature Comparison
Temperature Comparison
Exhaust Inspection
Fuel Dosing Line Check
Fuel Quality Check
Engine status
Temperature Comparison
Temperature Comparison
Exhaust Inspection
Fuel Dosing Line Check
Fuel Quality Check
Read DTCs and Store Snapshot Information
Engine status
Temperature Comparison
Temperature Comparison
Exhaust Inspection
Fuel Dosing Line Check
Fuel Quality Check
Engine status
Temperature Comparison
Temperature Comparison
Exhaust Inspection
Fuel Dosing Line Check
Fuel Quality Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Verify Correct Information Typed In
Verify Correct Part
ECU Reprogram
Clear DTCs
Read DTCs and Store Snapshot Information
Verify Correct Information Typed In
Verify Correct Part
ECU Reprogram
Clear DTCs
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Test for DTC
Smoke Test
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Read DTCs and Store Snapshot Information
Test for DTC
Smoke Test
Supply Circuit Check
Open or High Resistance Circuit Check
Signal Circuit Check
Software Check
Reprogram ECU
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Engine status
Temperature Comparison
Temperature Comparison
Engine status
Temperature Comparison
Temperature Comparison
Read DTCs and Store Snapshot Information
Engine status
Temperature Comparison
Temperature Comparison
Engine status
Temperature Comparison
Temperature Comparison
005018.15 – Calculated Unintended Combustibles In DOC Slightly High
005018.16 – Calculated Unintended Combustibles In DOC Moderately High
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Code Check
Terminal Check
Component Disconnected Code Check
Terminal Check
Component Disconnected Code Check
Terminal Check
ECU Disconnected Code Check
Short To Voltage Check
Wire to Wire Check
Wire to Wire Check
Component Reconnected Test
Signal Wire Voltage Check
Terminal Check
Continuity Check
Supply Wire Voltage Check
Terminal Check
Continuity Check
Component Reconnected Test
Signal Wire Voltage Check
Terminal Check
Continuity Check
Supply Wire Voltage Check
Terminal Check
Continuity Check
Component Reconnected Test
Signal Wire Voltage Check
Terminal Check
Continuity Check
Supply Wire Voltage Check
Terminal Check
Continuity Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Code Check
Terminal Check
Component Disconnected Code Check
Terminal Check
Component Disconnected Code Check
Terminal Check
ECU Disconnected Code Check
Short To Voltage Check
Wire to Wire Check
Wire to Wire Check
Component Reconnected Test
Signal Wire Voltage Check
Terminal Check
Continuity Check
Supply Wire Voltage Check
Terminal Check
Continuity Check
Component Reconnected Test
Signal Wire Voltage Check
Terminal Check
Continuity Check
Supply Wire Voltage Check
Terminal Check
Continuity Check
Component Reconnected Test
Signal Wire Voltage Check
Terminal Check
Continuity Check
Supply Wire Voltage Check
Terminal Check
Continuity Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Disconnected Component Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Supply Circuit Short to Ground Check
Component Reconnected Test
Terminal Check
Supply Wire Short To Ground Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Disconnected Component Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Supply Circuit Short to Ground Check
Component Reconnected Test
Terminal Check
Supply Wire Short To Ground Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Short To Voltage Check
Wire to Wire Check
Component Reconnected Test
Signal Wire Voltage Check
Terminal Check
Continuity Check
Supply Wire Voltage Check
Continuity Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
Terminal Check
Component Disconnected Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Short To Voltage Check
Wire to Wire Check
Component Reconnected Test
Signal Wire Voltage Check
Terminal Check
Continuity Check
Supply Wire Voltage Check
Continuity Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Active Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Supply Circuit Short to Ground Check
Component Reconnected Test
Terminal Check
Supply Wire Short To Ground Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
DTC List Review
Terminal Check
Active Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Supply Circuit Short to Ground Check
Component Reconnected Test
Terminal Check
Supply Wire Short To Ground Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Temperature Modules Check
Terminal Check
SCR Temperature Module Disconnected Code Check
Terminal Check
Aftertreatment Temperature Module Disconnected Code Check
Terminal Check
Intake Air Sensor Disconnected Code Check
Terminal Check
ECU Disconnected Code Check
Short to Unswitched Voltage Check
Wire To Wire Check
Short to Voltage Check
Terminal Check
Continuity Check
Short to Voltage Check
Terminal Check
Continuity Check
Short to Voltage Check
Terminal Check
Continuity Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
Temperature Modules Check
Terminal Check
SCR Temperature Module Disconnected Code Check
Terminal Check
Aftertreatment Temperature Module Disconnected Code Check
Terminal Check
Intake Air Sensor Disconnected Code Check
Terminal Check
ECU Disconnected Code Check
Short to Unswitched Voltage Check
Wire To Wire Check
Short to Voltage Check
Terminal Check
Continuity Check
Short to Voltage Check
Terminal Check
Continuity Check
Short to Voltage Check
Terminal Check
Continuity Check
Circuit Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
DTC List Review
DTC List Review
Terminal Check
Active Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Supply Circuit Short to Ground Check
Continuity Check
Temperature Modules Check
Continuity Check
Continuity Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Sensor Check
Intermittent Connection Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Read DTCs and Store Snapshot Information
DTC List Review
DTC List Review
Terminal Check
Active Code Check
Next Associated Sensor Check
Terminal Check
ECU Disconnected Code Check
Supply Circuit Short to Ground Check
Continuity Check
Temperature Modules Check
Continuity Check
Continuity Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Short Check
Sensor Check
Intermittent Connection Check
Read DTCs and Stored Snapshot Information
Obtain More Information
Terminal Check
Search DTAC Solutions
ECU Reprogram
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Wire to Wire Check
Verification
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Wire to Wire Check
Verification
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Short to Ground
Wire to Wire Check
Verification
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Short to Ground
Wire to Wire Check
Verification
005246.00 – SCR Operator Level #3 Derate Notification
005246.14 – SCR Operator Level #4 Derate Notification
005246.15 – SCR Operator Level #1 Derate Notification
005246.16 – SCR Operator Level #2 Derate Notification
005246.31 – SCR Operator Final Derate Notification
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Engine status
Temperature Comparison
Temperature Comparison
Age Check
Replace DOC
Engine status
Temperature Comparison
Temperature Comparison
Age Check
Replace DOC
Read DTCs and Store Snapshot Information
Engine status
Temperature Comparison
Temperature Comparison
Age Check
Replace DOC
Engine status
Temperature Comparison
Temperature Comparison
Age Check
Replace DOC
005298.18 – DOC Efficiency Moderately Low
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Code Check
Terminal Check
Code Check
Terminal Check
Code Check
Wire To Wire Check
Wire to Wire Check
Replace DEF Dosing Unit
DEF Dosing System Check
Read DTCs and Store Snapshot Information
Terminal Check
Code Check
Terminal Check
Code Check
Terminal Check
Code Check
Wire To Wire Check
Wire to Wire Check
Replace DEF Dosing Unit
DEF Dosing System Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Code Check
Terminal Check
Code Check
Terminal Check
Code Check
Continuity Check
Code Check
Wire To Wire Check
Wire to Wire Check
Replace DEF Dosing Unit
DEF Dosing System Check
Read DTCs and Store Snapshot Information
Terminal Check
Code Check
Terminal Check
Code Check
Terminal Check
Code Check
Continuity Check
Code Check
Wire To Wire Check
Wire to Wire Check
Replace DEF Dosing Unit
DEF Dosing System Check
Diagnostic Procedure
Preliminary Checks
DEF System Check
Test Results
Code Check
Engine Warm-up
Code Check
DEF Dosing System Check
Test Results
Code Check
Terminal Check
Continuity Check
DEF Dosing System Check
Component Check
DEF Dosing System Check
DEF Dosing System Check With Elevated DEF
DEF Dosing System Check
New DEF Dosing Unit Filter
New DEF Dosing Unit
Preliminary Checks
DEF System Check
Test Results
Code Check
Engine Warm-up
Code Check
DEF Dosing System Check
Test Results
Code Check
Terminal Check
Continuity Check
DEF Dosing System Check
Component Check
DEF Dosing System Check
DEF Dosing System Check With Elevated DEF
DEF Dosing System Check
New DEF Dosing Unit Filter
New DEF Dosing Unit
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Code Check
Terminal Check
Code Check
Terminal Check
Code Check
Continuity Check
Code Check
Wire To Wire Check
Wire to Wire Check
Replace DEF Dosing Unit
DEF Dosing System Check
Read DTCs and Store Snapshot Information
Terminal Check
Code Check
Terminal Check
Code Check
Terminal Check
Code Check
Continuity Check
Code Check
Wire To Wire Check
Wire to Wire Check
Replace DEF Dosing Unit
DEF Dosing System Check
Diagnostic Procedure
Preliminary Checks
Code Check
DEF Dosing System Check
DEF Dosing System Check
Engine Warm-up
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Supply Line Check
Supply Line Fitting Check
Return Line Check
Return Line Fitting Check
DEF Dosing System Check
Test Results
Engine Warm-up
Preliminary Checks
Code Check
DEF Dosing System Check
DEF Dosing System Check
Engine Warm-up
Terminal Check
Supply Circuit Check
Open or High Resistance Circuit Check
Terminal Check
Continuity Check
Supply Line Check
Supply Line Fitting Check
Return Line Check
Return Line Fitting Check
DEF Dosing System Check
Test Results
Engine Warm-up
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Measure Temperature
Terminal Check
Circuit Check
Wire to Wire Check
Terminal Check
Wire to Wire Check
Wire to Wire Check
Wire to Wire Check
Reprogram ECU
Heat Source Check
Read DTCs and Store Snapshot Information
Measure Temperature
Terminal Check
Circuit Check
Wire to Wire Check
Terminal Check
Wire to Wire Check
Wire to Wire Check
Wire to Wire Check
Reprogram ECU
Heat Source Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Measure Temperature
Terminal Check
Circuit Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Check
Wire to Wire Check
Wire to Wire Check
Reprogram ECU
Read DTCs and Store Snapshot Information
Measure Temperature
Terminal Check
Circuit Check
Wire to Wire Short Check
Terminal Check
Wire to Wire Check
Wire to Wire Check
Wire to Wire Check
Reprogram ECU
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Open Circuit Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Circuit Check
Software Check
Reprogram ECU
Terminal Check
Harness Check
Continuity Check
Circuit Check
Terminal Check
Terminal Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
+10 Volt Supply Check
+5 Volt Supply Check
Terminal Check
Wire to Wire Short Check
Wire to Wire Short Check
Short to Ground Check
Sensor Ground Check
Unswitched Voltage Check
Wire to Wire Short Check
Review DTC list
Review DTC list
Circuit Check
Circuit Check
Read DTCs and Store Snapshot Information
Terminal Check
+10 Volt Supply Check
+5 Volt Supply Check
Terminal Check
Wire to Wire Short Check
Wire to Wire Short Check
Short to Ground Check
Sensor Ground Check
Unswitched Voltage Check
Wire to Wire Short Check
Review DTC list
Review DTC list
Circuit Check
Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Wire to Wire Check
Replace DEF Dosing Unit
Read DTCs and Store Snapshot Information
Code Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Wire to Wire Check
Replace DEF Dosing Unit
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Terminal Check
Wire to Wire Check
Replace DEF Dosing Unit
Read DTCs and Store Snapshot Information
Terminal Check
Terminal Check
Terminal Check
Wire to Wire Check
Replace DEF Dosing Unit
005745.18 – DEF Dosing Unit Heater Temperature Moderately Low
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Wire to Wire Check
Wire to Wire Check
Replace DEF Dosing Unit
Read DTCs and Store Snapshot Information
Code Check
Code Check
Terminal Check
Terminal Check
Terminal Check
Continuity Check
Wire to Wire Check
Wire to Wire Check
Replace DEF Dosing Unit
520629.31 — ECU Illegal Input Map Structure Diagnostic Procedure
Reprogram ECU
Replace ECU
Reprogram ECU
Replace ECU
520956.05 – Battery Cutoff Relay Drive Circuit Has High Resistance
520956.06 – Battery Cutoff Relay Drive Circuit Has Low Resistance
521192.11 – Immobilizer Control Device Fault
521214.09 – Immobilizer Control Device Fault
521214.14 – Immobilizer Control Device Fault
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Reprogram ECU
Read DTCs and Store Snapshot Information
Reprogram ECU
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Voltage Check
Reprogram ECU
Read DTCs and Store Snapshot Information
Voltage Check
Reprogram ECU
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
Supply Voltage Check
Return Circuit Check
Read DTCs and Store Snapshot Information
Terminal Check
Supply Voltage Check
Return Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Air Bleed Check
Terminal Check
Supply Voltage Check
Return Circuit Check
Read DTCs and Store Snapshot Information
Air Bleed Check
Terminal Check
Supply Voltage Check
Return Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Active Code Check
Terminal Check
Supply Voltage Check
Return Circuit Check
Pump Enable Check
Terminal Check
Short to Ground Check
Continuity Check
Short Check
CAN Circuit Check
Terminal Check
Continuity Check
Harness Check
Circuit Check
Read DTCs and Store Snapshot Information
Active Code Check
Terminal Check
Supply Voltage Check
Return Circuit Check
Pump Enable Check
Terminal Check
Short to Ground Check
Continuity Check
Short Check
CAN Circuit Check
Terminal Check
Continuity Check
Harness Check
Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Read DTCs and Store Snapshot Information
Diagnostic Procedure
Read DTCs and Store Snapshot Information
DTC Check
Read DTCs and Store Snapshot Information
DTC Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Review DTC List
Terminal Check
Supply Voltage Check
CAN Circuit Check
Terminal Check
Continuity Check
Harness Check
Sensor Ground Check
Unswitched Voltage Check
Wire to Wire Short Check
Review DTC list
Review DTC list
Circuit Check
Circuit Check
Read DTCs and Store Snapshot Information
Review DTC List
Terminal Check
Supply Voltage Check
CAN Circuit Check
Terminal Check
Continuity Check
Harness Check
Sensor Ground Check
Unswitched Voltage Check
Wire to Wire Short Check
Review DTC list
Review DTC list
Circuit Check
Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Terminal Check
+10 Volt Supply Check
+5 Volt Supply Check
Terminal Check
Wire to Wire Short Check
Wire to Wire Short Check
Short to Ground Check
Sensor Ground Check
Unswitched Voltage Check
Wire to Wire Short Check
Review DTC list
Review DTC list
Circuit Check
Circuit Check
Read DTCs and Store Snapshot Information
Terminal Check
+10 Volt Supply Check
+5 Volt Supply Check
Terminal Check
Wire to Wire Short Check
Wire to Wire Short Check
Short to Ground Check
Sensor Ground Check
Unswitched Voltage Check
Wire to Wire Short Check
Review DTC list
Review DTC list
Circuit Check
Circuit Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Fuse Check
Short To Ground Check
Terminal Check
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Read DTCs and Store Snapshot Information
Fuse Check
Short To Ground Check
Terminal Check
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Verify Voltages to ECU and Ignition
Diagnostic Procedure
Read DTCs and Store Snapshot Information
ECU Shutdown
Code History
Read DTCs and Store Snapshot Information
ECU Shutdown
Code History
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Fuse Check
Terminal Check
Continuity Check
Short To Ground Check
Read DTCs and Store Snapshot Information
Fuse Check
Terminal Check
Continuity Check
Short To Ground Check
Diagnostic Procedure
Read DTCs and Store Snapshot Information
Fuse Check
Terminal Check
Continuity Check
Short To Ground Check
Read DTCs and Store Snapshot Information
Fuse Check
Terminal Check
Continuity Check
Short To Ground Check
523744.09 – A/C Clutch Status Message Not Received
Section 05 – TOOLS AND OTHER MATERIALS
Group 170 – Special Tools
75240
205466
313793
D01062AA
D01073AA
D01168AA
D01300AA
D05012ST-A
D05104ST
D05223ST
D17015BR
D17526CI
D17527CI
DFRG4
DFRG9
DFRG11
DFRG12
DFRG13
J-35616-20
JDE94
JDE41296
JDG164A
JDG360
JDG361
JDG362
JDG363
JDG364
JDG451
JDG777
JDG820
JDG968-1
JDG968-2
JDG968-3
JDG968-4
JDG968-5
JDG969A
JDG972
JDG978
JDG982A
JDG982AP2
JDG982AP3
JDG996
JDG998
JDG1144
JDG1167
JDG1333
JDG1334
JDG1449
JDG8092
JDG10042
JDG10057
JDG10059A
JDG10205
JDG10233
JDG10243
JDG10246A
JDG10249
JDG10254
JDG10273
JDG10357B
JDG10446
JDG10447
JDG10452
JDG10453
JDG10458
JDG10459
JDG10460
JDG10461
JDG10464
JDG10465
JDG10466
JDG10539
JDG10543
JDG10854
JDG10996
JDG10997
JDG11005
JDG11019
JDG11056
JDG11072
JDG11074
JDG11077
JDG11084
JDG11100A
JDG11101
JDG11186
JDG11202
JDG11233
JDG11263
JDG11311
JDG11311P2
JDG11315
JDG11324
JDG11325
JDG11325P1
JDG11325P2
JDG11373
JDG11375
JDG11409
JDG11594
JDG11684
JDG11796
JDG11831
JT03513C
JT05412
JT05470
JT05697A
JT05719
JT07253
JT07306
JT07336
SA1001
Group 180 – Lubricants, Sealants, and Other Materials
Other Materials
Section 06 – SPECIFICATIONS
Group 200 – Repair and General OEM Specifications
Metric Bolt and Screw Torque Values
Unified Inch Bolt and Screw Torque Values
Group 210 – Diagnostic Specifications
Engine Schematic 1
Engine Schematic 2
OEM Instrument Panel Schematic
13.5 L Wiring Diagram 1
13.5 L Wiring Diagram 2
13.5 L Wiring Diagram 3
13.5 L Wiring Diagram 4
13.5 L Wiring Diagram 5
13.5 L Wiring Diagram 6
13.5 L Wiring Diagram 7
13.5 L Wiring Diagram 8
13.5 L Wiring Diagram 9
13.5 L Wiring Diagram 10
13.5 L Wiring Diagram 11
13.5 L Wiring Diagram 12
13.5 L Wiring Diagram 13
Connector and Wire Splice Location Diagrams