John Deere CH570 and CH670 Sugar Cane Harvester Track and Wheel Machines (With Stage 2 or 3 Engine) Diagnostic Technical Manual TM155019 25JUL23

Introduction
Foreword
Contents
General Information
Safety
Recognize Safety Information
Understand Signal Words
Follow Safety Instructions
Prevent Machine Runaway
Handle Fluids Safely—Avoid Fires
Avoid Static Electricity Risk When Refueling
Prevent Battery Explosions
Prepare for Emergencies
In Case of Fire
Handling Batteries Safely
Handle Agricultural Chemicals Safely
Park Machine Safely
Support Machine Properly
Wear Protective Clothing
Work in Clean Area
Clean Vehicle of Hazardous Pesticides
Service Machines Safely
Work In Ventilated Area
Illuminate Work Area Safely
Replace Safety Signs
Use Proper Lifting Equipment
Wait Before Opening High-Pressure Fuel System
Service Accumulator Systems Safely
Avoid High-Pressure Fluids
Service Cooling System Safely
Use Steps and Handholds Correctly
Remove Paint Before Welding or Heating
Precautions for Welding
Avoid Heating Near Pressurized Fluid Lines
Service Tires Safely
Avoid Harmful Asbestos Dust
Practice Safe Maintenance
Avoid Hot Exhaust
Use Proper Tools
Construct Dealer-Made Tools Safely
Decommissioning—Proper Recycling and Disposal of Fluids and Components
Live With Safety
General References
Summary of References
Safety
General References
References for Technical Information
Information Available in Sections, Groups and Subgroups
Trademarks
Basic Diagnostic Philosophy
SEVEN BASIC STEPS
Know the System
Ask the Operator
Inspect the System
Operate the Machine (if possible)
List the Possible Causes
Reach a Conclusion
Test the Conclusion
TROUBLESHOOTING UNRESOLVED PROBLEMS
Problems Due to Specific Operating Conditions
Problems Due to Intermittent Electrical Failures
Problems Due to Control Unit Failures
Regions and Countries
Glossary of Terms
References for Technical Information
Metric Bolt and Screw Torque Values
Unified Inch Bolt and Screw Torque Values
Face Seal Fittings Assembly and Installation—All Pressure Applications
Face Seal O-Ring to Stud End Installation
Face Seal Adjustable Stud End O-Ring Installation
Face Seal Straight Stud End O-Ring Installation
Fitting Installation
Assembly Torque
Metric Face Seal and O-Ring Stud End Fitting Torque Chart—Standard Pressures
Metric Face Seal and O-Ring Stud End Fitting Torque Chart—High Pressure Applications
SAE Face Seal and O-Ring Stud End Fitting Torque Chart—Standard Pressures
SAE Face Seal and O-Ring Stud End Fitting Torque Chart—High Pressure Applications
Four Bolt Flange Fittings Assembly and Installation—All Pressure Applications
SAE Four Bolt Flange Cap Screw Torque Values—Standard Pressure Applications
SAE Four Bolt Flange Cap Screw Torque Values—High Pressure Applications
External Hexagon Port Plug Torque Chart
Diagnostic Trouble Codes (DTC)
Automatic Temperature Control Unit (ATC) Diagnostic Trouble Codes
ATC 000158.03— Heating and Air Conditioning
ATC 000158.04— Heating and Air Conditioning
ATC 000170.03— Heating and Air Conditioning
ATC 000170.04— Heating and Air Conditioning
ATC 000628.12— Heating and Air Conditioning
ATC 000639.14— CAN Bus System Problem
ATC 000871.03— Heating and Air Conditioning
ATC 000871.04— Heating and Air Conditioning
ATC 000871.13— ClimaTrak system
ATC 000871.18— Heating and Air Conditioning
ATC 000923.03— Heating and Air Conditioning
ATC 000923.04— Heating and Air Conditioning
ATC 000923.12— Heating and Air Conditioning
ATC 001546.03— Heating and Air Conditioning
ATC 001546.04— Heating and Air Conditioning
ATC 001547.03— Heating and Air Conditioning
ATC 001547.04— Heating and Air Conditioning
ATC 001548.03— Heating and Air Conditioning
ATC 001548.04— Heating and Air Conditioning
ATC 001549.03— Heating and Air Conditioning
ATC 001549.04— Heating and Air Conditioning
ATC 001549.07— Heating and Air Conditioning
ATC 001549.13— Heating and Air Conditioning
ATC 001551.03— Heating and Air Conditioning
ATC 001551.04— Heating and Air Conditioning
ATC 002000.09— Communication System
ATC 002071.09— Control Unit Communication System
ATC 002139.09— Communication System
ATC 003509.03— Heating and Air Conditioning
ATC 003509.04— Heating and Air Conditioning
ATC 003509.06— Heating and Air Conditioning
ATC 520870.02— Heating and Air Conditioning
ATC 520871.02— Heating and Air Conditioning
ATC 520872.02— Heating and Air Conditioning
ATC 523848.03— Heating and Air Conditioning
ATC 523848.04— Heating and Air Conditioning
ATC 523848.05— Heating and Air Conditioning
ATC 523848.06— Heating and Air Conditioning
ATC 523848.07— Heating and Air Conditioning
ATC 523848.13— Heating and Air Conditioning
ATC 524202.03— Heating and Air Conditioning
ATC 524202.04— Heating and Air Conditioning
Cab Control Unit (CAB) Diagnostic Trouble Codes
CAB 000158.00— Charging System
CAB 000158.01— Charging System
CAB 000158.18— Charging System
CAB 000190.01— Engine Speed
CAB 000237.02— Vehicle Identification System
CAB 000237.31— Vehicle Identification System
CAB 000629.12— CAB Control Unit
CAB 000639.12— CAN Bus System
CAB 000639.14— CAB Control Unit
CAB 000677.03— Engine Starter Motor Relay
CAB 000677.05— Engine Starter Motor Relay
CAB 000677.06— Engine Starter Motor Relay
CAB 000746.03— Differential Lock Solenoid Driver
CAB 000746.06— Differential Lock Solenoid Driver
CAB 001231.08— Local Link System-CAB/CPM B
CAB 001231.09— Local Link System-CAB/CPM A
CAB 001491.06— CAB Backlighting Driver
CAB 001503.03— Armrest Switch Matrix
CAB 001503.05— Armrest Switch Matrix
CAB 001504.04— Seat Switch
CAB 001865.11— Key Switch State
CAB 001867.06— Local Link System-CAB/CPM
CAB 002348.03— High Beam Headlights Driver
CAB 002348.05— High Beam Headlights Driver
CAB 002348.06— High Beam Headlights Driver
CAB 002386.03— Rotating Beacon Lights Driver
CAB 002386.06— Rotating Beacon Lights Driver
CAB 003509.03— CAB Sensor Supply Voltage 1
CAB 003509.04— CAB Sensor Supply Voltage 1
CAB 003510.03— CAB Sensor Supply Voltage 2
CAB 003510.04— CAB Sensor Supply Voltage 2
CAB 003597.06— ECU Supply Voltage
CAB 516663.04— Harvester Base Cutter Engage Switch
CAB 516790.03— Steering Column-Horn 2 Driver
CAB 516790.05— Steering Column-Horn 2 Driver
CAB 516790.06— Steering Column-Horn 2 Driver
CAB 516862.05— Armrest Display Wake Up Power
CAB 516862.06— Armrest Display Wake Up Power
CAB 517106.06— Down Force Control Setpoint
CAB 517115.14— Contour Basecutter Height Control Enable
CAB 517116.14— Crop Divider Float Option
CAB 520272.03— Map Light Driver
CAB 520272.06— Map Light Driver
CAB 520617.03— Refrigerator System Output Driver
CAB 520617.06— Refrigerator System Output Driver
CAB 520618.03— Multi-Function Lever Driver
CAB 520618.06— Multi-Function Lever Driver
CAB 520694.04— CPM B Power 5
CAB 520701.03— Right Header Extremity Light
CAB 520701.05— Right Header Extremity Light
CAB 520701.06— Right Header Extremity Light
CAB 520702.03— Left Header Extremity Light
CAB 520702.05— Left Header Extremity Light
CAB 520702.06— Left Header Extremity Light
CAB 521997.03— Left Window Wiper System Driver
CAB 521997.05— Left Window Wiper System Driver
CAB 521997.06— Left Window Wiper System Driver
CAB 521998.03— Right Window Wiper System Driver
CAB 521998.05— Right Window Wiper System Driver
CAB 521998.06— Right Window Wiper System Driver
CAB 522039.03— Seat Heater
CAB 522039.06— Seat Heater
CAB 522435.03— Front Wiper Motor Driver
CAB 522435.05— Front Wiper Motor Driver
CAB 522435.06— Front Wiper Motor Driver
CAB 522620.05— Steering column-Horn 1 Driver
CAB 522620.06— Steering column-Horn 1 Driver
CAB 522944.03— Cab Roof Light 1 Driver
CAB 522944.05— Cab Roof Light 1 Driver
CAB 522944.06— Cab Roof Light 1 Driver
CAB 522948.03— Road Light-Left Lower Driving Light Driver
CAB 522948.05— Road Light-Left Lower Driving Light Driver
CAB 522948.06— Road Light-Left Lower Driving Light Driver
CAB 523307.02— Engine Start Control
CAB 523307.03— Engine Start Control
CAB 523319.03— ECU Supply Voltage
CAB 523319.06— ECU Supply Voltage
CAB 523490.03— High Idle Indicator
CAB 523490.06— High Idle Indicator
CAB 523491.03— Mid Idle Indicator
CAB 523491.06— Mid Idle Indicator
CAB 523492.03— Low Idle Indicator
CAB 523492.06— Low Idle Indicator
CAB 523595.03— Right Lower Driving Lights Driver
CAB 523595.05— Right Lower Driving Lights Driver
CAB 523595.06— Right Lower Driving Lights Driver
CAB 523597.03— Front Beacon Light 2 Driver
CAB 523597.06— Front Beacon Light 2 Driver
CAB 523650.04— CPM A Power 5
CAB 523623.03— Switched Auxiliary Power 1
CAB 523623.06— Switched Auxiliary Power 1
CAB 523624.03— Cab Roof Lights 3, 6 Driver
CAB 523624.05— Cab Roof Lights 3, 6 Driver
CAB 523624.06— Cab Roof Lights 3, 6 Driver
CAB 523630.03— Cab Roof Lights 2, 7 Driver
CAB 523630.05— Cab Roof Lights 2, 7 Driver
CAB 523630.06— Cab Roof Lights 2, 7 Driver
CAB 523632.03— Cab Roof Light 8 Driver
CAB 523632.05— Cab Roof Light 8 Driver
CAB 523632.06— Cab Roof Light 8 Driver
CAB 523638.03— Road-Field Indicator Driver
CAB 523638.06— Road-Field Indicator Driver
CAB 523643.03— Multi-Function Lever Position Sensor Voltage High
CAB 523643.04— Multi-Function Lever Position Sensor Voltage Low
CAB 523643.07— Multi-Function Lever Position Switches Mismatch
CAB 523648.04— CPM A Power 4
CAB 523649.04— CPM A Power 3
CAB 523650.04— CPM A Power 2
CAB 523653.04— CPM A Power 1
CAB 523665.04— CAB Power 2
CAB 523666.04— CAB Power 1
CAB 523672.03— Pressurized Fan Motor Driver
CAB 523672.06— Pressurized Fan Motor Driver
CAB 523673.05— Chassis Ground
CAB 523746.03— Wake-Up Power System Driver
CAB 523746.04— Wake-Up Power System Driver
CAB 523746.06— Wake-Up Power System Driver
Cab Switch Module (CSM) Diagnostic Trouble Codes
CSM 000168.04— Electrical System
CSM 000628.02— CommandARM
CSM 000628.12— Electrical System
CSM 000629.12— Operator Controls
CSM 000630.02— CommandARM
CSM 000639.12— Communication System
CSM 000639.14— Cab Switch Module Control Unit Fault
CSM 002076.09— Communication System
CSM 520311.02— Communication System
CSM 520502.02— Operator Controls
CSM 522764.02— CommandARM
CSM 523625.02— Operator Controls
CSM 523746.03— Electrical System
CSM 523746.04— Electrical System
Cane Yield Monitor (CYM) Diagnostic Trouble Codes
CYM 000237.02— VIN Data Does Not Match the Other Control Units
Available Readings
Related Information
CYM 000237.09— VIN Message Was Not Detected
Available Readings
Related Information
CYM 000629.12— Controller Reset Due To a Timeout
Related Information
CYM 000639.12— CAN Message Incorrectly Received
Related Information
CYM 000639.14— CAN Bus Error Limit Exceeded
Related Information
CYM 516148.02— Camera Cable Problem
Related Information
CYM 516148.07— Camera is Mounted Upside Down
Related Information
Additional Information
CYM 516148.11— Camera Not Communicating
Related Information
CYM 516148.12— Camera Error
Related Information
CYM 516148.13— Camera Out of Calibration
Related Information
CYM 516148.14— Camera Lens is Dirty or View Obstructed
Related Information
CYM 516148.16— Camera Internal Temperature Limit Exceeded
Related Information
CYM 516380.02— Atom not communicating with XC
Related Information
CYM 516380.12— Controller Reprogramming Failure
Related Information
CYM 516380.16— Imagine Processing Module (IPM) Internal Temperature Limit Exceeded
Related Information
CYM 517191.02— Excessive Dropped Camera Packets
Related Information
CYM 517191.07— Camera Mounting Angle Out of Specification
Related Information
CYM 517191.12— Low Light Condition
Related Information
CYM 517191.13— Poor Empty Elevator State Detected
Related Information
CYM 517192.14— Material Buildup on the Elevator Detected
Related Information
CYM 517193.03— Camera Light 1 High Side Short to Power
Related Information
CYM 517193.05— Camera Light 1 High Side Open Circuit
Related Information
CYM 517193.06— Camera Light 1 High Side Short to Ground
Related Information
CYM 517194.03— Camera Light 2 High Side Short to Power
Related Information
CYM 517194.05— Camera Light 2 High Side Open Circuit
Related Information
CYM 517194.06— Camera Light 2 High Side Short to Ground
Related Information
CYM 517195.03— Camera Light 3 High Side Short to Power
Related Information
CYM 517195.05— Camera Light 3 High Side Open Circuit
Related Information
CYM 517195.06— Camera Light 3 High Side Short to Ground
Related Information
CYM 517196.03— Camera Light 4 High Side Short to Power
Related Information
CYM 517196.05— Camera Light 4 High Side Open Circuit
Related Information
CYM 517196.06— Camera Light 4 High Side Short to Ground
Related Information
CYM 521808.12— Elevator Commanded ON, But Speed is Zero
Related Information
ECU14 – Engine Control Unit (ECU) – Level 14 Diagnostic Trouble Codes
ECU 000091.09— CAN Bus System Problem
ECU 000094.03— Engine and Fuel Control System Problem
ECU 000094.04— Engine and Fuel Control System Problem
ECU 000094.17— Engine and Fuel Control System Problem
ECU 000097.03— Engine and Fuel Control System Problem
ECU 000097.04— Engine and Fuel Control System Problem
ECU 000097.16— Engine and Fuel Control System Problem
ECU 000100.01— Engine and Fuel Control System Problem
ECU 000100.04— Engine and Fuel Control System Problem
ECU 000100.18— Engine and Fuel Control System Problem
ECU 000100.31— Engine and Fuel Control System Problem
ECU 000102.02— Engine and Fuel Control System Problem
ECU 000102.03— Engine and Fuel Control System Problem
ECU 000102.04— Engine and Fuel Control System Problem
ECU 000103.00— Engine and Fuel Control System Problem
ECU 000103.05— Engine and Fuel Control System Problem
ECU 000103.08— Engine and Fuel Control System Problem
ECU 000103.31— Engine and Fuel Control System Problem
ECU 000105.00— Engine and Fuel Control System Problem
ECU 000105.03— Engine and Fuel Control System Problem
ECU 000105.04— Engine and Fuel Control System Problem
ECU 000105.15— Engine and Fuel Control System Problem
ECU 000105.16— Engine and Fuel Control System Problem
ECU 000107.00— Engine and Fuel Control System Problem
ECU 000108.02— Control Unit ECU Overall Problem
ECU 000110.00— Engine and Fuel Control System Problem
ECU 000110.03— Engine and Fuel Control System Problem
ECU 000110.04— Engine and Fuel Control System Problem
ECU 000110.15— Engine and Fuel Control System Problem
ECU 000110.16— Engine and Fuel Control System Problem
ECU 000110.17— Engine and Fuel Control System Problem
ECU 000157.03— Engine and Fuel Control System Problem
ECU 000157.04— Engine and Fuel Control System Problem
ECU 000157.10— Engine and Fuel Control System Problem
ECU 000157.17— Engine and Fuel Control System Problem
ECU 000158.17— Engine and Fuel Control System Problem
ECU 000174.00— Engine and Fuel Control System Problem
ECU 000174.03— Engine and Fuel Control System Problem
ECU 000174.04— Engine and Fuel Control System Problem
ECU 000174.16— Engine and Fuel Control System Problem
ECU 000189.00— Engine and Fuel Control System Problem
ECU 000190.00— Engine Speed
ECU 000412.00— Engine and Fuel Control System Problem
ECU 000412.03— Engine and Fuel Control System Problem
ECU 000412.04— Engine and Fuel Control System Problem
ECU 000412.15— Engine Exhaust Gas Recirculation Temperature
ECU 000412.16— Engine and Fuel Control System Problem
ECU 000611.03— Engine and Fuel Control System Problem
ECU 000611.04— Engine and Fuel Control System Problem
ECU 000627.01— Engine Power Supply
ECU 000629.12— Control Unit ECU Overall Problem
ECU 000629.13— Control Unit ECU Overall Problem
ECU 000636.02— Engine and Fuel Control System Problem
ECU 000636.05— Engine Position Sensor
ECU 000636.06— Engine Position Sensor
ECU 000636.08— Engine and Fuel Control System Problem
ECU 000636.10— Engine and Fuel Control System Problem
ECU 000637.02— Engine and Fuel Control System Problem
ECU 000637.05— Engine and Fuel Control System Problem
ECU 000637.06— Engine and Fuel Control System Problem
ECU 000637.07— Engine and Fuel Control System Problem
ECU 000637.08— Engine and Fuel Control System Problem
ECU 000637.10— Engine and Fuel Control System Problem
ECU 000640.31— Engine System
ECU 000641.04— Engine and Fuel Control System Problem
ECU 000641.12— Engine and Fuel Control System Problem
ECU 000641.13— Engine and Fuel Control System Problem
ECU 000641.16— Engine and Fuel Control System Problem
ECU 000651.02— Engine and Fuel Control System Problem
ECU 000651.05— Engine and Fuel Control System Problem
ECU 000651.06— Engine and Fuel Control System Problem
ECU 000651.07— Engine and Fuel Control System Problem
ECU 000651.13— Engine and Fuel Control System Problem
ECU 000652.02— Engine and Fuel Control System Problem
ECU 000652.05— Engine and Fuel Control System Problem
ECU 000652.06— Engine and Fuel Control System Problem
ECU 000652.07— Engine and Fuel Control System Problem
ECU 000652.13— Engine and Fuel Control System Problem
ECU 000653.02— Engine and Fuel Control System Problem
ECU 000653.05— Engine and Fuel Control System Problem
ECU 000653.06— Engine and Fuel Control System Problem
ECU 000653.07— Engine and Fuel Control System Problem
ECU 000653.13— Engine and Fuel Control System Problem
ECU 000654.02— Engine and Fuel Control System Problem
ECU 000654.05— Engine and Fuel Control System Problem
ECU 000654.06— Engine and Fuel Control System Problem
ECU 000654.07— Engine and Fuel Control System Problem
ECU 000654.13— Engine and Fuel Control System Problem
ECU 000655.02— Engine and Fuel Control System Problem
ECU 000655.05— Engine and Fuel Control System Problem
ECU 000655.06— Engine and Fuel Control System Problem
ECU 000655.07— Engine and Fuel Control System Problem
ECU 000655.13— Engine and Fuel Control System Problem
ECU 000656.02— Engine and Fuel Control System Problem
ECU 000656.05— Engine and Fuel Control System Problem
ECU 000656.06— Engine and Fuel Control System Problem
ECU 000656.07— Engine and Fuel Control System Problem
ECU 000656.13— Engine and Fuel Control System Problem
ECU 001075.12— Engine and Fuel Control System Problem
ECU 001136.00— Control Unit ECU Overall Problem
ECU 001136.16— Control Unit ECU Overall Problem
ECU 001172.03— Engine and Fuel Control System Problem
ECU 001172.04— Engine and Fuel Control System Problem
ECU 001180.00— Engine and Fuel Control System Problem
ECU 001180.16— Engine and Fuel Control System Problem
ECU 001347.03— Engine and Fuel Control System Problem
ECU 001347.05— Engine and Fuel Control System Problem
ECU 001347.07— Engine and Fuel Control System Problem
ECU 001569.31— Control Unit ECU Overall Problem
ECU 002630.00— Engine and Fuel Control System Problem
ECU 002630.03— Engine and Fuel Control System Problem
ECU 002630.04— Engine and Fuel Control System Problem
ECU 002630.15— Engine and Fuel Control System Problem
ECU 002630.16— Engine and Fuel Control System Problem
ECU 002659.02— Engine and Fuel Control System Problem
ECU 002659.15— Engine and Fuel Control System Problem
ECU 002659.17— Engine and Fuel Control System Problem
ECU 002790.16— Engine and Fuel Control System Problem
ECU 002791.02— Engine and Fuel Control System Problem
ECU 002791.07— Engine and Fuel Control System Problem
ECU 002791.13— Engine and Fuel Control System Problem
ECU 002791.31— Engine and Fuel Control System Problem
ECU 002795.07— Engine and Fuel Control System Problem
ECU 003353.31— Alternator State
ECU 003509.03— Engine and Fuel Control System Problem
ECU 003509.04— Engine and Fuel Control System Problem
ECU 003510.03— Engine and Fuel Control System Problem
ECU 003510.04— Engine and Fuel Control System Problem
ECU 003511.03— Engine and Fuel Control System Problem
ECU 003511.04— Engine and Fuel Control System Problem
ECU 003512.03— Engine and Fuel Control System Problem
ECU 003512.04— Engine and Fuel Control System Problem
ECU 003513.03— Engine and Fuel Control System Problem
ECU 003513.04— Engine and Fuel Control System Problem
Engine Interface Control Unit (EIC) Diagnostic Trouble Codes
EIC 000628.02— Electrical System
EIC 002000.09— Communication System
EIC 003695.14— Diesel Particulate Filter Regeneration Inhibit Switch
EIC 003719.15— Diesel Particulate Filter Regeneration Fault
EIC 003719.16— Calculated Soot Level High
EIC 523702.14— Flexpower Configuration
EIC 523702.31— Flexpower Configuration
Front Control Unit (FCU) Diagnostic Trouble Codes
FCU 000096.03— Fuel Level Sensor
FCU 000096.04— Fuel Level Sensor
FCU 000096.17— Fuel Level Sensor
FCU 000158.03— Wake-Up Power
FCU 000158.04— Wake-Up Power
FCU 000168.03— Battery Voltage
FCU 000168.04— Battery Voltage
FCU 000876.03— A/C Compressor Clutch Circuit
FCU 000876.05— A/C Compressor Clutch Circuit
FCU 000970.31— Engine Compartment Door Switch
FCU 001071.03— Cooling Fan Driver Circuit
FCU 001071.05— Cooling Fan Driver Circuit
FCU 002866.03— Front Windshield Washer Motor Output Driver
FCU 002866.05— Front Windshield Washer Motor Output Driver
FCU 516119.03— Side Windshield Washer Motor Output Driver
FCU 516119.04— Side Windshield Washer Motor Output Driver
FCU 516119.05— Side Windshield Washer Motor Output Driver
FCU 516709.03— RH Side Knife Travel Up Driver
FCU 516709.05— RH Side Knife Travel Up Driver
FCU 516709.06— RH Side Knife Travel Up Driver
FCU 516720.03— Propulsion Valve Power 3 Output Driver
FCU 516720.05— Propulsion Valve Power 3 Output Driver
FCU 516720.06— Propulsion Valve Power 3 Output Driver
FCU 516721.03— Propulsion Valve Power 4 Output Driver
FCU 516721.05— Propulsion Valve Power 4 Output Driver
FCU 516721.06— Propulsion Valve Power 4 Output Driver
FCU 516725.03— LH Side Knife Travel Up Driver
FCU 516725.05— LH Side Knife Travel Up Driver
FCU 516725.06— LH Side Knife Travel Up Driver
FCU 516726.03— RH Side Knife Travel Down Driver
FCU 516726.05— RH Side Knife Travel Down Driver
FCU 516726.06— RH Side Knife Travel Down Driver
FCU 516727.03— LH Side Knife Travel Down Driver
FCU 516727.05— LH Side Knife Travel Down Driver
FCU 516727.06— LH Side Knife Travel Down Driver
FCU 516728.03— Left Hand Side Knife Driver
FCU 516728.05— Left Hand Side Knife Driver
FCU 516728.06— Left Hand Side Knife Driver
FCU 516728.07— Left Hand Side Knife Travel Control
FCU 516729.03— Right Hand Side Knife Driver
FCU 516729.05— Right Hand Side Knife Driver
FCU 516729.06— Right Hand Side Knife Driver
FCU 516729.07— Right Hand Side Knife Travel Control
FCU 517013.07— Elevator Swing Left First Detent Switch
FCU 517014.07— Elevator Swing Left Second Detent Switch
FCU 517015.07— Elevator Swing Right First Detent Switch
FCU 517016.07— Elevator Swing Right Second Detent Switch
FCU 521794.06— Cooling Fan PWM Low Side Driver
FCU 521794.12— Cooling Fan PWM Low Side Driver
FCU 521814.07— Knockdown Roller Control
FCU 521815.03— Primary Extractor Fan PWM Low Side Driver
FCU 521815.05— Primary Extractor Fan PWM Low Side Driver
FCU 521815.06— Primary Extractor Fan Return Driver
FCU 521815.13— Primary Extractor Fan System
FCU 521816.07— Primary Extractor Hood Control Switch
FCU 521817.03— Primary Extractor Hood Rotate CW Output Driver
FCU 521817.05— Primary Extractor Hood Rotate CW Output Driver
FCU 521817.06— Primary Extractor Hood Rotate CW Output Driver
FCU 521818.03— Primary Extractor Hood Rotate CCW Output Driver
FCU 521818.05— Primary Extractor Hood Rotate CCW Output Driver
FCU 521818.06— Primary Extractor Hood Rotate CCW Output Driver
FCU 521819.03— Elevator Swing Left Driver
FCU 521819.05— Elevator Swing Left Driver
FCU 521819.06— Elevator Swing Left Driver
FCU 521820.03— Elevator Swing Right Driver
FCU 521820.05— Elevator Swing Right Driver
FCU 521820.06— Elevator Swing Right Driver
FCU 521820.07— Elevator Swing Control
FCU 521821.03— Knockdown Roller In Driver
FCU 521821.05— Knockdown Roller In Driver
FCU 521821.06— Knockdown Roller In Driver
FCU 521822.03— Knockdown Roller Out Driver
FCU 521822.05— Knockdown Roller Out Driver
FCU 521822.06— Knockdown Roller Out Driver
FCU 521823.03— Topper Lower Driver
FCU 521823.05— Topper Lower Driver
FCU 521823.06— Topper Lower Driver
FCU 521824.03— Topper Raise Driver
FCU 521824.05— Topper Raise Driver
FCU 521824.06— Topper Raise Driver
FCU 521824.07— Topper Lift Controls
FCU 521825.03— Left Hand Side Topper Throw Output Driver
FCU 521825.05— Left Hand Side Topper Throw Output Driver
FCU 521825.06— LH Side Topper Throw Output Driver
FCU 521826.03— Right Hand Side Topper Throw Output Driver
FCU 521826.05— Right Hand Side Topper Throw Output Driver
FCU 521826.06— RH Side Topper Throw Output Driver
FCU 521832.03— Harvesting Function Valve Reverse Driver
FCU 521832.05— Harvesting Function Valve Reverse Driver
FCU 521832.06— Harvesting Function Valve Reverse Driver
FCU 521833.03— Harvesting Function Valve Forward Driver
FCU 521833.05— Harvesting Function Valve Forward Driver
FCU 521833.06— Harvesting Function Valve Forward Driver
FCU 521860.07— Left Hand Crop Divider Tilt Control
FCU 521861.07— Right Hand Crop Divider Tilt Control
FCU 521862.03— Right Hand Crop Divider Tilt Up Driver
FCU 521862.05— Right Hand Crop Divider Tilt Up Driver
FCU 521862.06— Right Hand Crop Divider Tilt Up Driver
FCU 521863.03— Right Hand Crop Divider Tilt Down Driver
FCU 521863.05— Right Hand Crop Divider Tilt Down Driver
FCU 521863.06— Right Hand Crop Divider Tilt Down Driver
FCU 521864.03— Left Hand Crop Divider Tilt Down Driver
FCU 521864.05— Left Hand Crop Divider Tilt Down Driver
FCU 521864.06— Left Hand Crop Divider Tilt Down Driver
FCU 521865.03— Left Hand Crop Divider Tilt Up Driver
FCU 521865.05— Left Hand Crop Divider Tilt Up Driver
FCU 521865.06— Left Hand Crop Divider Tilt Up Driver
FCU 521873.03— Chopper Rev Driver
FCU 521873.05— Chopper Rev Driver
FCU 521873.06— Chopper Rev Driver
FCU 521875.03— Chopper Fwd Driver
FCU 521875.05— Chopper Fwd Driver
FCU 521875.06— Chopper Fwd Driver
FCU 521876.03— Base Cutter Rev Driver
FCU 521876.05— Base Cutter Rev Driver
FCU 521876.06— Base Cutter Rev Driver
FCU 521877.03— Base Cutter Fwd Driver
FCU 521877.05— Base Cutter Fwd Driver
FCU 521877.06— Base Cutter Fwd Driver
FCU 521878.06— Base Cutter PWM Low Side Driver
FCU 521879.03— Primary Extractor Fan High Side Driver
FCU 521879.05— Primary Extractor Fan High Side Driver
FCU 521879.06— Primary Extractor Fan High Side Driver
FCU 521894.00— Chopper Motor Pressure Sensor
FCU 521894.01— Chopper Motor Pressure Sensor
FCU 521894.03— Chopper Motor Pressure Sensor
FCU 521894.04— Chopper Motor Pressure Sensor
FCU 522947.03— Right Lower Road Light Driver
FCU 522947.05— Right Lower Road Light Driver
FCU 522947.06— Right Lower Road Light Driver
FCU 522948.03— Left Lower Road Light Driver
FCU 522948.05— Left Lower Road Light Driver
FCU 522948.06— Left Lower Road Light Driver
FCU 523215.03— Driver Interlock
FCU 523215.04— Driver Interlock
FCU 523219.03— Valve Power Supply
FCU 523219.04— Valve Power Supply
FCU 523315.00— Primary Extractor Fan Speed Sensor
FCU 523315.31— Primary Extractor Fan Speed Sensor
FCU 524124.03— Cooling Fan
FCU 524124.05— Cooling Fan
FCU 524124.06— Cooling Fan Reverse Valve
FCU 524124.14— Cooling Fan
FCU 524124.31— Cooling Fan
Improved Height Control Unit (IHU) Diagnostic Trouble Codes
IHU 000629.12— Control Unit
IHU 000639.12— Communication System
IHU 000639.14— Communication System
IHU 001515.13— Electronic Header Height System
IHU 002019.09— Communication System
IHU 002023.09— Communication System
IHU 002039.09— Communication System
IHU 003509.03— Sensor Supply 1 Voltage High
IHU 003509.04— Sensor Supply 1 Voltage Low
IHU 003509.06— Sensor Supply 1 Current High
IHU 003510.03— Sensor Supply 2 Voltage High
IHU 003510.04— Sensor Supply 2 Voltage Low
IHU 003510.06— Sensor Supply 2 Current High
IHU 003511.03— Sensor Supply 3 Voltage High
IHU 003511.04— Sensor Supply 3 Voltage Low
IHU 516120.03— Right Hand Crop Divider Accumulator Shutoff valve
IHU 516120.05— Right Hand Crop Divider Accumulator Shutoff Valve
IHU 516120.06— Right Hand Crop Divider Accumulator Shutoff Valve
IHU 516121.03— Left Hand Crop Divider Accumulator Shutoff valve
IHU 516121.05— Left Hand Crop Divider Accumulator Shutoff Valve
IHU 516121.06— Left Hand Crop Divider Accumulator Shutoff Valve
IHU 516716.03— Right Hand Base Cutter Height Lower Output Driver
IHU 516716.05— Right Hand Base Cutter Height Lower Output Driver
IHU 516716.06— Right Hand Base Cutter Height Lower Output Driver
IHU 516717.03— Left Hand Base Cutter Height Lower Output Driver
IHU 516717.05— Left Hand Base Cutter Height Lower Output Driver
IHU 516717.06— Left Hand Base Cutter Height Lower Output Driver
IHU 516733.03— Base Cutter Height Proportional Valve Low Side Driver
IHU 516733.05— Base Cutter Height Proportional Valve Low Side Driver
IHU 516733.06— Base Cutter Height Proportional Valve High Side Driver
IHU 516916.05— Base Cutter Shut Off Valve Output Driver
IHU 516916.06— Base Cutter Shut Off Valve Output Driver
IHU 517017.07— Base Cutter Lower First Detent Switch
IHU 517018.07— Base Cutter Lower Second Detent Switch
IHU 517019.07— Base Cutter Raise First Detent Switch
IHU 517020.07— Base Cutter Raise Second Detent Switch
IHU 521384.03— Left Hand CD Pressure Sensor
IHU 521384.04— Left Hand CD Pressure Sensor
IHU 521384.13— Left Crop Divider Pressure Sensor Calibration
IHU 521385.03— Right Hand CD Pressure Sensor
IHU 521385.04— Right Hand CD Pressure Sensor
IHU 521385.13— Right Crop Divider Pressure Sensor Calibration
IHU 521809.07— Right Hand Crop Divider Position Driver
IHU 521810.07— Left Hand Crop Divider Position Driver
IHU 521866.03— Left Hand Crop Divider Raise and Lower Low Side Driver
IHU 521866.05— Left Hand Crop Divider Raise and Lower Low Side Driver
IHU 521866.06— Left Hand Crop Divider Raise and/or Lower High Side Driver
IHU 521867.03— Right Hand Crop Divider Raise and Lower Low Side Driver
IHU 521867.05— Right Hand Crop Divider Raise and Lower Low Side Driver
IHU 521867.06— Right Hand Crop Divider Raise and/or Lower High Side Driver
IHU 521880.07— Base Cutter Lower Driver
IHU 521881.07— Base Cutter Raise Driver
IHU 521882.00— Left Hand Crop Divider Position Sensor
IHU 521882.01— Left Hand Crop Divider Position Sensor
IHU 521882.13— Left Crop Divider Position Sensor Calibration
IHU 521884.00— Right Hand Crop Divider Position Sensor
IHU 521884.01— Right Hand Crop Divider Position Sensor
IHU 521884.13— Right Crop Divider Position Sensor Calibration
IHU 521885.03— Right Hand Base Cutter Lift Position Sensor
IHU 521885.04— Right Hand Base Cutter Lift Position Sensor
IHU 521885.15— Right Hand Base Cutter Lift Position Sensor
IHU 521885.17— Right Hand Base Cutter Lift Position Sensor
IHU 521886.03— Left Hand Base Cutter Lift Position Sensor
IHU 521886.04— Left Hand Base Cutter Lift Position Sensor
IHU 521886.15— Left Hand Base Cutter Lift Position Sensor
IHU 521886.17— Left Hand Base Cutter Lift Position Sensor
IHU 521887.13— Base Cutter Target Height Range Calibration
IHU 523318.00— Base Cutter Motor Pressure Sensor
IHU 523318.01— Base Cutter Motor Pressure Sensor
IHU 523318.03— Base Cutter Motor Pressure Sensor
IHU 523318.04— Base Cutter Motor Pressure Sensor
Multi – Function Control Handle (MHC) Diagnostic Trouble Codes
MHC 000628.12— Control Unit MHC Problem
MHC 000639.14— Multi-Function Lever
MHC 520618.12— Multi-Function Lever
MHC 522606.07— Multi-Function Lever
MHC 522607.07— Multi-Function Lever
MHC 522607.11— Multi-Function Lever
MHC 522611.07— Multi-Function Lever
MHC 522612.07— Multi-Function Lever
MHC 522614.07— Multi-Function Lever
MHC 522615.07— Multi-Function Lever
MHC 522616.07— Multi-Function Lever
MHC 522617.07— Multi-Function Lever
MHC 522643.07— Multi-Function Lever
MHC 522645.07— Multi-Function Lever
MHC 522647.07— Multi-Function Lever
MHC 522649.07— Multi-Function Lever
MHC 522651.07— Multi-Function Lever
MHC 522652.07— Multi-Function Lever
MHC 522653.07— Multi-Function Lever
MHC 522654.07— Multi-Function Lever
MHC 522655.07— Multi-Function Lever
MHC 522656.07— Multi-Function Lever
MHC 522657.07— Multi-Function Lever
MHC 522659.07— Multi-Function Lever
MHC 522661.07— Multi-Function Lever
MHC 522663.07— Multi-Function Lever
MHC 522665.07— Multi-Function Lever
MHC 523335.07— Multi-Function Lever
MHC 523336.07— Multi-Function Lever
MHC 523339.07— Multi-Function Lever
Primary Display Unit (PDU) Diagnostic Trouble Codes
PDU 000628.02— Operator Controls
PDU 000628.12— Programming
PDU 000629.12— Electrical System
PDU 000639.12— Communication System
PDU 000639.14— Communication System
PDU 002000.09— Communication System
PDU 002003.09— Communication System
PDU 002019.09— Communication System
PDU 002038.09— Communication System
PDU 002039.09— Communication System
Propulsion and Steering Control Unit (PSC) Diagnostic Trouble Codes
PSC 000070.02— Park-Not Park status
PSC 000070.14— Park Brake
PSC 000168.03— Steering System
PSC 000168.04— Steering System
PSC 000237.31— Communication System
PSC 000517.09— Communication System
PSC 000628.02— Steering System
PSC 000628.12— Programming
PSC 000629.12— Steering System
PSC 000630.13— Steering System
PSC 001504.09— Communication System
PSC 001504.14— AutoTrac™ System
PSC 001638.09— Hydraulic Oil Temperature
PSC 002000.09— Communication System
PSC 003509.03— Steering System
PSC 003509.04— Steering System
PSC 003510.03— Control Lever
PSC 003510.04— Control Lever
PSC 003511.03— Transmission
PSC 003511.04— Transmission
PSC 003512.03— Steering System
PSC 003512.04— Steering System
PSC 003648.13— Transmission Neutral
PSC 520296.05— Transmission
PSC 520296.06— Transmission
PSC 520297.05— Transmission
PSC 520297.06— Transmission
PSC 520298.05— Transmission
PSC 520298.06— Transmission
PSC 520299.05— Transmission
PSC 520299.06— Transmission
PSC 520378.00— Transmission
PSC 520378.01— Transmission
PSC 520378.05— Transmission
PSC 520378.06— Transmission
PSC 520378.31— Transmission
PSC 520379.00— Transmission
PSC 520379.01— Transmission
PSC 520379.05— Transmission
PSC 520379.06— Transmission
PSC 520379.16— Transmission
PSC 520379.31— Transmission
PSC 520380.00— Transmission
PSC 520380.01— Transmission
PSC 520380.05— Transmission
PSC 520380.06— Transmission
PSC 520380.16— Transmission
PSC 520380.31— Transmission
PSC 520381.00— Transmission
PSC 520381.01— Transmission
PSC 520381.05— Transmission
PSC 520381.06— Transmission
PSC 520381.31— Transmission
PSC 520628.09— Steering Track Bias
PSC 522261.13— Steering System
PSC 522265.03— Steering System
PSC 522265.16— Steering System
PSC 522266.03— Steering System
PSC 522266.16— Steering System
PSC 522363.00— Transmission
PSC 522363.01— Transmission
PSC 522363.02— Transmission System
PSC 522363.03— Transmission
PSC 522363.04— Transmission
PSC 522363.05— Transmission
PSC 522363.07— Transmission
PSC 522363.08— Transmission
PSC 522363.10— Transmission
PSC 522363.14— Transmission
PSC 522363.16— Transmission
PSC 522363.31— Transmission
PSC 522379.00— Transmission
PSC 522379.01— Transmission
PSC 522379.05— Transmission
PSC 522379.06— Transmission
PSC 522381.00— Transmission
PSC 522381.01— Transmission
PSC 522381.02— Transmission System
PSC 522381.03— Transmission
PSC 522381.04— Transmission
PSC 522381.05— Transmission
PSC 522381.07— Transmission
PSC 522381.08— Transmission
PSC 522381.10— Transmission
PSC 522381.14— Transmission
PSC 522381.16— Transmission
PSC 522381.31— Transmission
PSC 522394.09— Communication System
PSC 522777.13— Steering System
PSC 522855.13— Transmission
PSC 522856.13— Transmission
PSC 523216.00— Transmission
PSC 523216.01— Transmission
PSC 523217.00— Transmission
PSC 523217.01— Transmission
PSC 523218.01— Transmission
PSC 523219.01— Transmission
PSC 523326.13— Transmission
PSC 523345.00— Multi-Function Lever Secondary Position Sensor Voltage Above Normal
PSC 523345.01— Multi-Function Lever Secondary Position Sensor Voltage Below Normal
PSC 523345.03— Multi-Function Lever Secondary Position Sensor Voltage High
PSC 523345.04— Multi-Function Lever Secondary Position Sensor Voltage Low
PSC 523345.14— Multi-Function Lever Position Sensors Mismatch
PSC 523380.31— Transmission
PSC 523498.14— Transmission
PSC 523643.00— Multi-Function Lever Primary Position Sensor Voltage Above Normal
PSC 523643.01— Multi-Function Lever Primary Position Sensor Voltage Below Normal
PSC 523643.03— Multi-Function Lever Primary Position Sensor Voltage High
PSC 523643.04— Multi-Function Lever Primary Position Sensor Voltage Low
PSC 523643.07— Multi-Function Lever Not In Neutral at Start-Up
PSC 523643.13— Multi-Function Lever Primary Position Sensors Not Calibrated
PSC 523643.14— Multi-Function Lever Position Sensors Mismatch
PSC 523651.02— Steering System
PSC 523660.03— Steering System
PSC 523660.16— Steering System
PSC 523661.11— Steering System
PSC 523661.31— Steering System
PSC 523698.09— Communication System
PSC 523767.02— Steering System
PSC 523911.00— Hydro Control Valve
PSC 523911.01— Hydro Control Valve
PSC 523911.05— Hydro Control Valve
PSC 523911.06— Hydro Control Valve
PSC 523953.03— Control Lever
PSC 523953.04— Control Lever
PSC 523953.14— Control Lever
PSC 524160.02— Neutral-Not Neutral status
PSC 524221.09— Communication System
PSC 524232.00— Park Brake Pressure
PSC 524232.01— Park Brake Pressure
PSC 524232.03— Park Brake Pressure
PSC 524232.04— Park Brake Pressure
PSC 524232.07— Park Brake Pressure
PSC 524232.16— Park Brake Pressure
PSC 524232.18— Park Brake Pressure
PSC 524249.14— Transmission
PSC 524254.03— Transmission Enable Relay
PSC 524254.04— Transmission Enable Relay
Power Control Unit (PTP) Diagnostic Trouble Codes
PTP 000070.02— Park-Not Park status
PTP 000070.14— Park Brake
PTP 000168.03— Steering System
PTP 000168.04— Steering System
PTP 000237.31— Communication System
PTP 000628.02— Steering System
PTP 000628.12— Programming
PTP 000629.12— Steering System
PTP 001504.14— AutoTrac™ System
PTP 001638.09— Hydraulic Oil temperature
PTP 002000.09— Communication System
PTP 003509.03— Steering System
PTP 003509.04— Steering System
PTP 003510.03— Control Lever
PTP 003510.04— Control Lever
PTP 003511.03— Transmission
PTP 003511.04— Transmission
PTP 003512.03— Steering System
PTP 003512.04— Steering System
PTP 003648.13— Transmission Neutral
PTP 520296.05— Transmission
PTP 520296.06— Transmission
PTP 520297.05— Transmission
PTP 520297.06— Transmission
PTP 520298.05— Transmission
PTP 520298.06— Transmission
PTP 520299.05— Transmission
PTP 520299.06— Transmission
PTP 520378.00— Transmission
PTP 520378.01— Transmission
PTP 520378.05— Transmission
PTP 520378.06— Transmission
PTP 520378.31— Transmission
PTP 520379.00— Transmission
PTP 520379.01— Transmission
PTP 520379.05— Transmission
PTP 520379.06— Transmission
PTP 520379.16— Transmission
PTP 520379.31— Transmission
PTP 520380.00— Transmission
PTP 520380.01— Transmission
PTP 520380.05— Transmission
PTP 520380.06— Transmission
PTP 520380.16— Transmission
PTP 520380.31— Transmission
PTP 520381.00— Transmission
PTP 520381.01— Transmission
PTP 520381.05— Transmission
PTP 520381.06— Transmission
PTP 520381.31— Transmission
PTP 522363.00— Transmission
PTP 522363.01— Transmission
PTP 522363.03— Transmission
PTP 522363.04— Transmission
PTP 522363.05— Transmission
PTP 522363.07— Transmission
PTP 522363.08— Transmission
PTP 522363.10— Transmission
PTP 522363.14— Transmission
PTP 522363.16— Transmission
PTP 522363.31— Transmission
PTP 522379.00— Transmission
PTP 522379.01— Transmission
PTP 522379.05— Transmission
PTP 522379.06— Transmission
PTP 522381.00— Transmission
PTP 522381.01— Transmission
PTP 522381.03— Transmission
PTP 522381.04— Transmission
PTP 522381.05— Transmission
PTP 522381.07— Transmission
PTP 522381.08— Transmission
PTP 522381.10— Transmission
PTP 522381.14— Transmission
PTP 522381.16— Transmission
PTP 522381.31— Transmission
PTP 522855.13— Transmission
PTP 522856.13— Transmission
PTP 523216.00— Transmission
PTP 523216.01— Transmission
PTP 523217.00— Transmission
PTP 523217.01— Transmission
PTP 523218.01— Transmission
PTP 523219.01— Transmission
PTP 523326.13— Transmission
PTP 523345.00— Multi-Function Lever Secondary Position Sensor Voltage Above Normal
PTP 523345.01— Multi-Function Lever Secondary Position Sensor Voltage Below Normal
PTP 523345.03— Multi-Function Lever Secondary Position Sensor Voltage High
PTP 523345.04— Multi-Function Lever Secondary Position Sensor Voltage Low
PTP 523345.14— Multi-Function Lever Position Sensors Mismatch
PTP 523380.31— Transmission
PTP 523498.14— Transmission
PTP 523643.00— Multi-Function Lever Primary Position Sensor Voltage Above Normal
PTP 523643.01— Multi-Function Lever Primary Position Sensor Voltage Below Normal
PTP 523643.03— Multi-Function Lever Primary Position Sensor Voltage High
PTP 523643.04— Multi-Function Lever Primary Position Sensor Voltage Low
PTP 523643.07— Multi-Function Lever Not In Neutral at Start-Up
PTP 523643.13— Multi-Function Lever Primary Position Sensors Not Calibrated
PTP 523643.14— Multi-Function Lever Position Sensors Mismatch
PTP 523651.02— Transmission
PTP 523661.11— Steering System
PTP 523911.00— Transmission System
PTP 523911.01— Transmission
PTP 523911.03— Transmission
PTP 523911.04— Transmission
PTP 523911.05— Transmission
PTP 523911.06— Transmission
PTP 523911.13— Transmission
PTP 523953.03— Control Lever
PTP 523953.04— Control Lever
PTP 523953.14— Control Lever
PTP 524160.02— Neutral-Not Neutral status
PTP 524232.01— Park Brake Pressure
PTP 524232.03— Park Brake Pressure
PTP 524232.04— Park Brake Pressure
PTP 524232.16— Park Brake Pressure
PTP 524232.18— Park Brake Pressure
PTP 524249.14— Transmission
PTP 524254.03— Transmission Enable Relay
PTP 524254.04— Transmission Enable Relay
Rear Control Unit (RCU) Diagnostic Trouble Codes
RCU 000111.01— Coolant Level Sensor
RCU 000158.03— Wake-Up Power
RCU 000158.04— Wake-Up Power
RCU 000168.03— Battery Voltage
RCU 000168.04— Battery Voltage
RCU 001508.00— Hydraulic Oil Reservoir Temperature Sensor
RCU 001508.03— Hydraulic Oil Reservoir Temperature Sensor
RCU 001508.04— Hydraulic Oil Reservoir Temperature Sensor
RCU 001508.15— Hydraulic Oil Reservoir Temperature Sensor
RCU 001713.16— Hydraulic Oil Filter
RCU 002368.03— Left Turn Signal Lights Driver
RCU 002368.05— Left Turn Signal Lights Driver
RCU 002368.06— Left Turn Signal Lights Driver
RCU 002370.03— Right Turn Signal Lights Driver
RCU 002370.05— Right Turn Signal Lights Driver
RCU 002370.06— Right Turn Signal Lights Driver
RCU 002372.03— Left Stop Light Driver
RCU 002372.05— Left Stop Light Driver
RCU 002372.06— Left Stop Light Driver
RCU 002374.03— Right Stop Light Driver
RCU 002374.05— Right Stop Light Driver
RCU 002374.06— Right Stop Light Driver
RCU 002602.14— Hydraulic Oil Level
RCU 003353.31— Alternator State
RCU 003510.03— Sensor Supply Voltage 2
RCU 003510.04— Sensor Supply Voltage 2
RCU 516445.03— License Plate Light Driver
RCU 516445.05— License Plate Light Driver
RCU 516445.06— License Plate Light Driver
RCU 516602.03— Secondary Extractor Hood Clockwise Driver
RCU 516602.05— Secondary Extractor Hood Clockwise Driver
RCU 516602.06— Secondary Extractor Hood Clockwise Driver
RCU 516665.03— Secondary Extractor Hood Counter Clockwise Driver
RCU 516665.05— Secondary Extractor Hood Counter Clockwise Driver
RCU 516665.06— Secondary Extractor Hood Counter Clockwise Driver
RCU 516687.03— Secondary Extractor Engage Driver
RCU 516687.05— Secondary Extractor Engage Driver
RCU 516687.06— Secondary Extractor Engage Driver
RCU 516688.03— Left Rear Beacon Light Power Driver
RCU 516688.05— Left Rear Beacon Light Power Driver
RCU 516688.06— Left Rear Beacon Light Power Driver
RCU 516689.03— Right Rear Beacon Light Power Driver
RCU 516689.05— Right Rear Beacon Light Power Driver
RCU 516689.06— Right Rear Beacon Light Power Driver
RCU 516690.03— Engine Work Light 1 Driver
RCU 516690.05— Engine Work Light 1 Driver
RCU 516690.06— Engine Work Light 1 Driver
RCU 516691.03— Engine Work Light 2 Driver
RCU 516691.05— Engine Work Light 2 Driver
RCU 516691.06— Engine Work Light 2 Driver
RCU 516692.03— Left Elevator Field Light Power Driver
RCU 516692.05— Left Elevator Field Light Power Driver
RCU 516692.06— Left Elevator Field Light Power Driver
RCU 516693.03— Right Elevator Field Light Power Driver
RCU 516693.05— Right Elevator Field Light Power Driver
RCU 516693.06— Right Elevator Field Light Power Driver
RCU 516694.03— Left Field Light Power
RCU 516694.05— Left Field Light Power
RCU 516694.06— Left Field Light Power
RCU 516695.03— Right Field Light Power
RCU 516695.05— Right Field Light Power
RCU 516695.06— Right Field Light Power
RCU 516696.07— Elevator Vertical Position Switches
RCU 516697.07— Secondary Extractor Hood Control
RCU 516700.03— Harvester Elevator Forward Driver
RCU 516700.05— Harvester Elevator Forward Driver
RCU 516700.06— Harvester Elevator Forward Driver
RCU 516701.01— Primary Hydraulic Oil Level
RCU 516755.03— Back Up Alarm Horn Output Driver
RCU 516755.05— Back Up Alarm Horn Output Driver
RCU 516755.06— Back Up Alarm Output Driver
RCU 516770.03— Left Reverse Lamp Valve Driver
RCU 516770.05— Left Hand Reverse Lamp Valve Driver
RCU 516770.06— Left Hand Reverse Lamp Valve Driver
RCU 516773.03— Right Hand Reverse Lamp Valve Driver
RCU 516773.05— Right Hand Reverse Lamp Valve Driver
RCU 516773.06— Right Hand Reverse Lamp Valve Driver
RCU 517012.03— Auxiliary Power Driver
RCU 517012.05— Auxiliary Power Driver
RCU 517012.06— Auxiliary Power Driver
RCU 521433.03— Elevator Reverse Driver
RCU 521433.05— Elevator Reverse Driver
RCU 521433.06— Elevator Reverse Driver
RCU 521434.03— Elevator Raise Driver
RCU 521434.05— Elevator Raise Driver
RCU 521434.06— Elevator Raise Driver
RCU 521435.03— Elevator Lower Driver
RCU 521435.05— Elevator Lower Driver
RCU 521435.06— Elevator Lower Driver
RCU 521437.03— Bin Flap Raise Driver
RCU 521437.05— Bin Flap Raise Driver
RCU 521437.06— Bin Flap Raise Driver
RCU 521438.03— Bin Flap Lower Driver
RCU 521438.05— Bin Flap Lower Driver
RCU 521438.06— Bin Flap Lower Driver
RCU 521439.07— Bin Flap Position Switches
RCU 521808.00— Elevator Speed Sensor
RCU 521830.03— Elevator Proportional Valve Low Side Driver
RCU 521830.04— Elevator Proportional Valve Low Side Driver
RCU 521830.05— Elevator Proportional Valve Low Side Driver
RCU 521830.06— Elevator Proportional Valve Low Side Driver
RCU 523219.03— Valve Power Supply
RCU 523219.04— Valve Power Supply
RCU 523290.00— Rear Feed Speed Sensor
RCU 523565.03— Vehicle Left Marker Light Valve Driver
RCU 523565.05— Vehicle Left Marker Light Valve Driver
RCU 523565.06— Vehicle Left Marker Light Valve Driver
RCU 523614.03— Vehicle Right Marker Light Valve Driver
RCU 523614.05— Vehicle Right Marker Light Valve Driver
RCU 523614.06— Vehicle Right Marker Light Valve Driver
Steering Column Control Unit (SCL) Diagnostic Trouble Codes
SCL 000639.14— CAN Bus System Problem
SCL 002863.02— Steering Column Lever
SCL 002866.02— Steering Column Lever
SCL 002872.02— Steering Column Lever
SCL 002873.02— Steering Column Lever
SCL 002874.02— Steering Column Lever
SCL 002876.02— Steering Column Lever
SCL 522008.07— Steering Column Lever
SCL 522620.03— Steering Column Lever
SCL 522620.05— Steering Column Lever
SCL 522620.06— Steering Column Lever
AutoTrac Exit Codes
AutoTrac™ Exit Codes
Observable Symptom and System Diagnostics
Engine
Engine Will Not Crank
Engine Hard to Start or Will Not Start
Engine Misfiring or Runs Irregularly
Lack of Engine Power
Fuel, Air Intake, Exhaust and Cooling Systems
Engine Overheats
Electrical or Electrohydraulic Systems
Air Filter Restriction Electrical Problem
Available Readings
Related Information
Alternator and Battery Problem
Available Readings
Related Information
Armrest Switch Matrix Problem
Available Readings
Related Information
Auxiliary Field Lights Problem
Available Readings
Related Information
Auxiliary Power Outlets Problem
Related Information
Auxiliary Power Problem
Related Information
Auxiliary Power Strip Problem
Related Information
Base Cutter Drive Electrical Problem
Available Readings
Related Information
Base Cutter Up and Down Electrical (Track) Problem
Available Readings
Related Information
Base Cutter Up and Down Electrical (Wheel) Problem
Available Readings
Related Information
Brake Pedal Electrical Problem—Wheel Machines
Available Readings
Related Information
Cab Beacon Lights Problem
Available Readings
Related Information
Cab CAN Bus Problem
Related Information
Cab Field Lights Problem
Available Readings
Related Information
Cab Road Lights Problem
Available Readings
Related Information
Chopper Drive Electrical Problem
Available Readings
Related Information
Cooling Fan Electrical Problem
Available Readings
Related Information
Coolant Level Electrical Problem (Tier 2-Stage II and Tier 3-Stage IIIA Emissions)
Available Readings
Related Information
Crop Divider Lift Electrical Problem
Available Readings
Related Information
Crop Divider Tilt Electrical Problem
Available Readings
Related Information
Dome Light Electrical Problem
Related Information
Elevator Discharge Flap Electrical Problem
Available Readings
Related Information
Elevator Discharge Flap Electrical Problem
Available Readings
Related Information
Elevator Drive Electrical Problem
Available Readings
Related Information
Elevator Swing Electrical Problem
Available Readings
Related Information
Elevator Up and Down Electrical Problem
Available Readings
Related Information
Engine Work Lights Problem
Available Readings
Related Information
Floating Crop Divider Electrical Problem
Available Readings
Related Information
Front Turn Lights and Rear Vehicle Lights Problem
Available Readings
Related Information
Fuel Level Electrical Problem
Available Readings
Related Information
Fuel Transfer Pump Electrical Problem (Tier 2-Stage II and Tier 3-Stage IIIA Emissions)
Available Readings
Related Information
Ground Drive Electrical Problem
Available Readings
Stand-alone Tests
Related Information
Harvest Functions Electrical Problem
Available Readings
Related Information
Heating, Ventilating, and Air Conditioning Electrical Problem
Available Readings
Related Information
Horn Problem
Available Readings
Related Information
Hydraulic Oil Level, Temperature and Filter Restriction Electrical Problem
Available Readings
Related Information
Knock Down Roller Tilt Electrical Problem
Available Readings
Related Information
License Lamp, Front Turn and Signal Lights Problem (CE)
Available Readings
Related Information
Lower Driving Lights Problem (CE)
Related Information
Main CAN Bus Problem
Related Information
Map Light Problem
Available Readings
Related Information
Mirror Position and Heater Electrical Problem
Related Information
Park Brake Electrical Problem—Track Machines
Available Readings
Related Information
Park Brake Electrical Problem—Wheel Machines
Available Readings
Related Information
PCP Unloading Electrical Problem
Related Information
Power Seat & Presence Switch Electrical Problem
Available Readings
Related Information
Primary Extractor Electrical Problem
Available Readings
Related Information
Quick Stop Problem
Available Readings
Related Information
Radio Problem
Related Information
Rear Beacon Lights Problem
Available Readings
Related Information
Refrigerator Electrical Problem
Available Readings
Related Information
Reverse Alarm Electrical Problem
Available Readings
Related Information
Secondary Extractor Electrical Problem
Available Readings
Related Information
Side Knives Electrical Problem
Available Readings
Related Information
Speedometer Problem
Available Readings
Related Information
Diagnostic Procedure
Starter Electrical Problem
Available Readings
Related Information
System Wakeup Power Problem
Related Information
Topper Electrical Problem
Available Readings
Related Information
Vehicle Electrical Center (VEC) Problem
Related Information
Wiper and Washer Problem
Available Readings
Related Information
Electronic Control Units
Cab CAN Bus or Local Link Problem
Related Information
Vehicle CAN Bus Problem
Related Information
Automatic Temperature Control Unit (ATC) Power Problem
Related Information
Cab Control Unit (CAB) Power Problem
Available Readings
Related Information
Cab Switch Module (CSM) Power Problem
Available Readings
Related Information
Engine Control Unit (ECU) Level 14 (T2 or T3) Power Problem
Available Readings
Related Information
Front Control Unit (FCU) Power Problem
Available Readings
Related Information
Multi-Function Lever Control Unit (MHC) Power Problem
Related Information
Primary Display Unit (PDU) Power Problem
Available Readings
Related Information
Propulsion and Steering Control Unit (PSC) Power Problem
Available Readings
Related Information
Propulsion Control Unit (PTP)  Power Problem
Available Readings
Related Information
Rear Control Unit (RCU) Power Problem
Available Readings
Related Information
Steering Control Lever (SCL) Power Problem
Related Information
Drivetrain
Low Machine Power
Neutral Malfunction
Hydrostatic System Operating Hot
Steering and Brakes
Park Brake Hydraulic Problem
Related Information
Steering Hydraulic Problem (Wheel Machine)
Related Information
Hydraulics
Base Cutter Drive Hydraulic Problem
Type Identification
Related Information
Base Cutter Lift Hydraulic Problem
Related Information
Billet Selector Hydraulic Problem
Related Information
Bin Flap Hydraulic Problem
Related Information
Butt-lifter Drive Hydraulic Problem
Related Information
Chopper Hydraulic Problem
Type Identification
Related Information
Chopper Curtain Agitator Drive Hydraulic Problem
Related Information
Cooling Fan Drive Hydraulic Problem
Related Information
Crop Divider Drive Hydraulic Problem
Related Information
Crop Divider Lift Hydraulic Problem
Related Information
Crop Divider Tilt Hydraulic Problem
Related Information
Elevator Drive Hydraulic Problem
Type Identification
Related Information
Elevator Lift Hydraulic Problem
Related Information
Elevator Swing Hydraulic Problem
Related Information
Feed Roller Drive Hydraulic Problem
Related Information
Knockdown Roller Drive Hydraulic Problem
Related Information
Knockdown Roller Tilt Hydraulic Problem
Related Information
Outer Scroll Drive Hydraulic Problem
Related Information
Primary Extractor Drive Hydraulic Problem
Related Information
Primary Extractor Hood Rotate Hydraulic Problem
Related Information
Secondary Extractor Drive Hydraulic Problem
Related Information
Secondary Extractor Hood Rotate Hydraulic Problem
Related Information
Side Knives Drive Hydraulic Problem
Related Information
Side Knife Tilt Hydraulic Problem
Related Information
Sill Roller Drive Hydraulic Problem
Related Information
Topper Drive Hydraulic Problem
Related Information
Topper Lift Hydraulic Problem
Related Information
Cab
HVAC (Heating, Ventilation and Air Conditioning) Problem
Available Readings
Related Information
Engine
General Information
Summary of References
John Deere 6090 Engine
Engine Specifications
Available Engine Options:
Engine Specifications – Tier 2/Stage II (6090HT807)
Engine Specifications – Tier 3/Stage IIIA (6090HT806)
Theory of Operation
John Deere Engine Theory of Operation (6090HT806)
337 HP (Standard)
375 HP (High Performance)
John Deere Engine Theory of Operation (6090HT807)
337 HP (Standard)
375 HP (High Performance)
Schematics
ECU Schematic (6090HT806)
ECU Schematic (6090HT807)
Tests and Adjustments
Cooling System Check
Diagnose Turbocharger Malfunctions
Fuel, Air Intake, Exhaust and Cooling
General Information
Summary of References
John Deere 6090 Engine
Operational and Preliminary Checks
Check Air Intake
Check Engine Coolant Level
Check Engine Oil Level
Check Fuel System
Check Fuel Tank Breather
Theory of Operation
Air Intake and Exhaust System Theory of Operation (6090HT806)
Air Intake—
Charge Air Cooler—
Exhaust—
Additional Information—
Air Intake and Exhaust System Theory of Operation (6090HT807)
Air Intake—
Charge Air Cooler—
Exhaust—
Additional Information—
Cooling System Theory of Operation (6090HT806)
Additional Information
Cooling System Theory of Operation (6090HT807)
Additional Information
Fuel System Theory of Operation (6090HT806)
Fuel System Theory of Operation (6090HT807)
Tests and Adjustments
Charge Air Cooler Test
Cooling System Test—Machine
Surge Tank Cap Test
Fuel, Air Intake, Exhaust, and Cooling Diagnostics
Electrical System
General Information
Summary of References
Electrical Designators
Visually Inspect Electrical System
Standard Electrical Symbols
Circuit Checks
High Resistance (Voltage Drop) Test
Open Ground Circuit Check
Open Supply Circuit Check
Short to Ground
Short to Higher Voltage
Open Circuit Load Test
Testing Circuits Using Open Circuit Load Tester
Testing Control Unit Power Circuits Using Open Circuit Load Tester
Testing Control Unit Ground Circuits Using Open Circuit Load Tester (Chassis or Single Point Ground)
Testing Component Ground Circuits Using Open Circuit Load Tester (Chassis or Single Point Ground)
Connector Terminal Test
Wire Harness Test
Alternator Test Procedure
Electrical Component Identification
Operational and Preliminary Checks
Battery Voltage Check
Diode Check
Diagnostic Trouble Codes—After Machine Repair
Intermittent Diagnostic Trouble Code (DTC) Diagnostics
Power Distribution Theory of Operation
Alternator and Battery Theory of Operation
Auxiliary Power Theory of Operation
Auxiliary Power Outlets Theory of Operation
Auxiliary Power Strip Theory of Operation
System Wakeup Power Theory of Operation
Vehicle Electrical Center (VEC) Theory of Operation
Fuse Identification
System Wakeup Power Fuse
Lighting Theory of Operation
Auxiliary Field Lights Theory of Operation
Cab Beacon Lights Theory of Operation
Cab Field Lights Theory of Operation
Cab Road Lights Theory of Operation
Dome Light Theory of Operation
Engine Work Lights Theory of Operation
Front Turn Lights and Rear Vehicle Lights Theory of Operation
Turn Lights
Hazard Warning Lights
Running Lights
Brake Lights
Reverse Lights
Related Information
License Lamp, Front Turn and Signal Lights Theory of Operation (CE)
Turn Lights
Hazard Warning Lights
Running Lights and License Lamp
Lower Driving Lights Theory of Operation (CE)
Map Light Theory of Operation
Rear Beacon Lights Theory of Operation
Cab Electrical Theory of Electrical Operation
Armrest Switch Matrix Theory of Operation
Heating, Ventilating, and Air Conditioning Theory of Operation
Horn Theory of Operation
Mirror Position and Heater Theory of Operation
Mirror Position
Mirror Heater
Multi-function Lever Position Theory of Operation
Related Information
Power Seat & Presence Switch Theory of Operation
Presence Switch
Air Seat
Seat Heater
Quick Stop Theory of Operation
Radio Theory of Operation
Refrigerator Theory of Operation
Wiper and Washer Theory of Operation
Front Wiper and Washer
Side Wiper and Washer (If Equipped)
Engine Electrical Theory of Operation
Air Filter Restriction Theory of Operation
Coolant Level Theory of Operation
Fuel Level Theory of Operation
Fuel Transfer Pump Theory of Operation
Starter Theory of Operation
Key Switch Run Position
Key Switch Start Position
Transmission and Drive Systems Electrical Theory of Operation
Brake Pedals Theory of Operation (Wheel)
Reverse Alarm Theory of Operation
Transmission Theory of Operation
Ground Drive (Track Machines)
Ground Drive (Track Machines 2-Speed)
Ground Drive (Wheel Machines)
Neutral Gate
Park Brake
Positive Traction (Wheel Machines)
Steering Wheel
Varitorq (Wheel Machines)
Electro – Hydraulic Systems Electrical Theory of Operation
Base Cutter Forward and Reverse Theory of Operation
Base Cutter Up and Down Theory of Operation (Track)
Base Cutter Up
Base Cutter Down
Contour Base Cutter Height Control
Base Cutter Up and Down Theory of Operation (Wheel)
Base Cutter Up
Base Cutter Down
Contour Base Cutter Height Control
Chopper Theory of Operation
Cooling Fan Theory of Operation
Related Information
Crop Divider Tilt Theory of Operation
Left-hand Crop Divider Tilt Up
Left-hand Crop Divider Tilt Down
Right-hand Crop Divider Tilt Up
Right-hand Crop Divider Tilt Down
Crop Divider Up and Down Theory of Operation
Left-hand Crop Divider Up
Left-hand Crop Divider Down
Right-hand Crop Divider Up
Right-hand Crop Divider Down
Floating Crop Dividers
Elevator Discharge Theory of Operation
Elevator Discharge Flap Out
Elevator Discharge Flap In
Elevator Forward and Reverse Theory of Operation
Elevator Forward
Elevator Reverse
Elevator Speed Control
Elevator Swing Theory of Operation
Elevator Swing Left
Elevator Swing Right
Elevator Up and Down Theory of Operation
Elevator Up
Elevator Down
Harvesting Functions Theory of Operation
Harvesting Functions Forward
Harvesting Functions Reverse
Hydraulic Oil Level, Temperature and Filter Restriction Theory of Operation
Hydraulic Oil Level
Hydraulic Oil Temperature
Hydraulic Filter Restriction
Knockdown Rollers Theory of Operation
Knockdown Roller Raise
Knockdown Roller Lower
PCP Unloading Theory of Operation
Primary Extractor Theory of Operation
Primary Extractor Fan
Primary Extractor Hood Rotate
Secondary Extractor Theory of Operation
Secondary Extractor Fan
Secondary Extractor Hood Rotate
Side Knives Theory of Operation
Side Knives Rotation
Left-hand Side Knife Engage
Right-hand Side Knife Engage
Side Knives Raise and Lower
Left-hand Side Knife Raise
Left-hand Side Knife Lower
Right-hand Side Knife Raise
Right-hand Side Knife Lower
Topper Theory of Operation
Topper Rotation
Left-hand Topper Engage
Right-hand Topper Engage
Topper Raise and Lower
Topper Raise
Topper Lower
CAN Bus Systems Theory of Operation
Main CAN Bus Theory of Operation
Cab CAN Bus Theory of Operation
Material Handling Theory of Operation
Cane Yield Monitor Theory of Operation
Functional Schematics
SE-01—Power and Ground Electrical Schematics (Cab)
SE-01—Power and Ground Electrical (Cab)-Schematics 1/2
SE-01—Power and Ground Electrical (Cab)-Schematics 2/2
SE-02—CAN Bus Electrical Schematics (Cab)
SE-03—In-Cab Electrical Schematics
SE-03—In-Cab Electrical-Schematics 1/11
SE-03—In-Cab Electrical-Schematics 2/11
SE-03—In-Cab Electrical-Schematics 3/11
SE-03—In-Cab Electrical-Schematics 4/11
SE-03—In-Cab Electrical-Schematics 5/11
SE-03—In-Cab Electrical-Schematics 6/11
SE-03—In-Cab Electrical-Schematics 7/11
SE-03—In-Cab Electrical-Schematics 8/11
SE-03—In-Cab Electrical-Schematics 9/11
SE-03—In-Cab Electrical-Schematics 10/11
SE-03—In-Cab Electrical-Schematics 11/11
SE-04—HVAC Electrical Schematics
SE-05—ISG Systems Electrical Schematics (Cab)
SE-05—ISG Systems Electrical (Cab)-Schematics 1/2
SE-05—ISG Systems Electrical (Cab)-Schematics 2/2
SE-06—Power and Ground Electrical Schematics (Vehicle)
SE-06—Power and Ground Electrical (Vehicle)-Schematics 1/2
SE-06—Power and Ground Electrical (Vehicle)-Schematics 2/2
SE-07—CAN Bus Electrical Schematics (Vehicle)
SE-08—Cooling System Electrical Schematics
SE-09—Transmission Electrical Schematics
SE-10—Harvesting Functions Electrical Schematics
SE-10—Harvesting Functions Electrical-Schematics 1/7
SE-10—Harvesting Functions Electrical-Schematics 2/7
SE-10—Harvesting Functions Electrical-Schematics 3/7
SE-10—Harvesting Functions Electrical-Schematics 4/7
SE-10—Harvesting Functions Electrical-Schematics 5/7
SE-10—Harvesting Functions Electrical-Schematics 6/7
SE-10—Harvesting Functions Electrical-Schematics 7/7
SE-11—Elevator System Electrical Schematics
SE-11—Elevator System Electrical-Schematics 1/2
SE-11—Elevator System Electrical-Schematics 2/2
SE-12—Vehicle Lighting Electrical Schematics
SE-12—Vehicle Lighting Electrical-Schematics 1/3
SE-12—Vehicle Lighting Electrical-Schematics 2/3
SE-12—Vehicle Lighting Electrical-Schematics 3/3
SE-13—Engine Electrical Schematics (Tier 2-Stage II and Tier 3-Stage IIIA Emissions)
SE-13—Engine Electrical (Tier 2-Stage II and Tier 3-Stage IIIA Emissions)-Schematics 1/2
SE-13—Engine Electrical (Tier 2-Stage II and Tier 3-Stage IIIA Emissions)-Schematics 2/2
SE-15—Miscellaneous Electrical Schematics
SE-15—Miscellaneous Electrical-Schematics 1/3
SE-15—Miscellaneous Electrical-Schematics 2/3
SE-15—Miscellaneous Electrical-Schematics 3/3
Power Distribution Schematics
Alternator and Battery Electrical Schematic
Auxiliary Power Outlets Electrical Schematic
Auxiliary Power Strip Electrical Schematic
Auxiliary Power Electrical Schematic
System Wakeup Power Electrical Schematic
Vehicle Electrical Center (VEC) Electrical Schematic
Lighting Schematics
Auxiliary Field Lights Electrical Schematic
Cab Beacon Lights Electrical Schematic
Cab Field Lights Electrical Schematic
Cab Road Lights Electrical Schematic
Dome Light Electrical Schematic
Engine Work Lights Electrical Schematic
Front Turn Lights and Rear Vehicle Lights Electrical Schematic
License Lamp, Front Turn and Signal Lights Electrical Schematic (CE)
Lower Driving Lights Electrical Schematic (CE)
Map Light Electrical Schematic
Rear Beacon Lights Electrical Schematic
Cab Electrical Schematics
Armrest Switch Matrix Electrical Schematic
Heating, Ventilating, and Air Conditioning Electrical Schematic
Horn Electrical Schematic
Mirror Position and Heater Electrical Schematic
Multi-function Lever Position Schematic
Related Information
Power Seat & Presence Switch Electrical Schematic
Quick Stop Electrical Schematic
Radio Electrical Schematic
Refrigerator Electrical Schematic
Pin Function
Related Information
Wiper and Washer Electrical Schematic
Engine Electrical Schematics
Air Filter Restriction Electrical Schematic
Coolant Level Electrical Schematic
Fuel Level Electrical Schematic
Fuel Transfer Pump Electrical Schematic
Starter Electrical Schematic
Transmission and Drive Systems Electrical Schematics
Brake Pedals Electrical Schematic (Wheel)
Reverse Alarm Electrical Schematic
Transmission Electrical Schematic
Electro – Hydraulic Systems Electrical Schematics
Base Cutter Forward and Reverse Electrical Schematic
Base Cutter Up and Down Electrical Schematic (Track)
Base Cutter Up and Down Electrical Schematic (Wheel)
Chopper Electrical Schematic
Cooling Fan Electrical Schematic
Crop Divider Tilt Electrical Schematic
Crop Divider Up and Down Electrical Schematic
Elevator Discharge Electrical Schematic
Elevator Forward and Reverse Electrical Schematic
Elevator Swing Electrical Schematic
Elevator Up and Down Electrical Schematic
Harvesting Functions Electrical Schematic
Hydraulic Oil Level, Temperature and Filter Restriction Electrical Schematic
Knockdown Rollers Electrical Schematic
PCP Unloading Electrical Schematic
Primary Extractor Electrical Schematic
Secondary Extractor Electrical Schematic
Side Knives Electrical Schematic
Topper Electrical Schematic
CAN Bus Systems Schematic
Main CAN Bus Schematic
Main CAN Bus Communication Schematic
Main CAN Bus Power Schematic
Circuit Identification
Cab CAN Bus Schematic
Circuit Identification
Cab CAN Bus Schematic
Circuit Identification
Material Handling Schematic
Yield Monitor Schematic
Pin Identification—A59 Rear Control Unit (RCU)
Pin Identification—A86 Secondary Display Unit (SDU)
Pin Identification—A102 Main CAN Bus Passive Terminator
Pin Identification—A200 Cane Yield Monitor Control Unit (CYM)
Pin Identification—A201 Wireless Communication Radio
Power Distribution Diagnostic Procedures
Alternator and Battery Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Auxiliary Power Diagnostics
Related Information
Diagnostic Procedure
Auxiliary Power Outlets Diagnostics
Related Information
Diagnostic Procedure
Auxiliary Power Strip Diagnostics
Related Information
Diagnostic Procedure
System Wakeup Power Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Vehicle Electrical Center (VEC) Diagnostics
Related Information
Diagnostic Procedure
Lighting Diagnostic Procedures
Auxiliary Field Lights Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Cab Beacon Lights Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Cab Field Lights Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Cab Road Lights Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Dome Light Electrical Diagnostics
Related Information
Diagnostic Procedure
Engine Work Lights Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Front Turn Lights and Rear Vehicle Lights Diagnostics
Available Readings
Related Information
Diagnostic Procedure
License Lamp, Front Turn and Signal Lights Diagnostics (CE)
Available Readings
Related Information
Diagnostic Procedure
Lower Driving Lights Diagnostics (CE)
Related Information
Diagnostic Procedure
Map Light Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Rear Beacon Lights Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Cab Electrical Diagnostic Procedures
Armrest Switch Matrix Diagnostics
Available Readings
Related Information
Heating, Ventilating, and Air Conditioning Electrical Diagnostics
Available Readings
Related Information
Horn Diagnostics
Available Readings
Related Information
Mirror Position and Heater Electrical Diagnostics
Related Information
Power Seat & Presence Switch Electrical Diagnostics
Available Readings
Related Information
Quick Stop Diagnostics
Available Readings
Related Information
Diagnostic
Radio Diagnostics
Related Information
Diagnostic Procedure
Refrigerator Electrical Diagnostics
Available Readings
Related Information
Wiper and Washer Diagnostics
Available Readings
Related Information
Diagnostic Strategy
Engine Electrical Diagnostic Procedures
Air Filter Restriction Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Coolant Level Electrical Diagnostics (Tier 2-Stage II and Tier 3-Stage IIIA Emissions)
Available Readings
Related Information
Fuel Level Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Fuel Transfer Pump Electrical Diagnostics (Tier 2-Stage II and Tier 3-Stage IIIA Emissions)
Available Readings
Related Information
Diagnostic Procedure
Starter Electrical Diagnostics
Available Readings
Related Information
Transmission and Drive Systems Electrical Diagnostic Procedures
Brake Pedal Electrical Diagnostics—Wheel Machines
Available Readings
Related Information
Diagnostic Procedure
Park Brake Electrical Diagnostics—Track Machines
Available Readings
Related Information
Diagnostic Procedure
Park Brake Electrical Diagnostics—Wheel Machines
Available Readings
Related Information
Diagnostic Procedure
Reverse Alarm Electrical Diagnostics
Available Readings
Related Information
Ground Drive Electrical Diagnostics
Available Readings
Stand-alone Tests
Related Information
Diagnostic Procedure
Electro – Hydraulic Systems Electrical Diagnostic Procedures
Base Cutter Drive Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Base Cutter Up and Down Electrical (Wheel) Diagnostics
Available Readings
Related Information
Base Cutter Up and Down Electrical (Track) Diagnostics
Available Readings
Related Information
Chopper Drive Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Cooling Fan Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Crop Divider Tilt Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Crop Divider Lift Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Elevator Discharge Flap Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Elevator Drive Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Elevator Swing Electrical Diagnostics
Available Readings
Related Information
Elevator Up and Down Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Floating Crop Divider Electrical Diagnostics
Available Readings
Related Information
Harvest Functions Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Hydraulic Oil Level, Temperature and Filter Restriction Electrical Diagnostics
Available Readings
Related Information
Knock Down Roller Tilt Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedure
PCP Unloading Electrical Diagnostics
Related Information
Diagnostic Procedure
Primary Extractor Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedures
Secondary Extractor Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedures
Side Knives Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedure
Topper Electrical Diagnostics
Available Readings
Related Information
Diagnostic Procedure
CAN Bus Systems Diagnostic Procedures
Main CAN Bus Diagnostics
Related Information
Cab CAN Bus Diagnostics
Related Information
CAN Bus Voltage Check
CAN Bus Circuit Check
Communication Loss From Individual Control Units
Communication Loss From Multiple Control Units In A Specific Order
Communication Loss Of All Control Units
Material Handling Diagnostic Procedures
Basic Runoff Test
Section 1. IPM Controller Test
Test Case 2
Section 2. Sugarcane Yield Monitoring Application:
Section 3: Next VT Feature with Two 2630 Displays
Test Case 5
Test Case 6
Section 4: Yield Monitor Camera:
Yield Camera Communication Status
Section 5: Yield Monitor Sensor Camera Lights:
Test Case 9
Test Case 10
Section 6: Yield Monitor Camera Lens Dirtiness and View Obstruction:
Dirtiness Threshold and Gauge:
Verify:
Camera View Selection:
Section 7: Yield Monitor System Readiness:
Engage Elevator:
Verify:
Row Width:
Verify
GPS Signal:
Verify:
Navigation Based Wheel Speed:
Engage Elevator, Run at Normal Speed:
Verify:
Section 9: Communication Radio Mounted on Harvester:
Verify:
Test Case 20
Verify:
Section 10: Manual Yield Calibration Page:
Advance Runoff Test
HDOC Harvest Documentation Setup
IPM Configuration
HDOC Data Recording and Load Data Saving
Verify Save Load File
Yield Monitor Diagnostics
Related Information
Diagnostic Procedure
Electronic Control Units
General Information
Summary of References
Diagnostic Address Types
Icons
Electrical Control Units – Definitions
Servicing Electronic Control Units
Welding Near Electronic Control Units
Keep Electronic Control Unit Connectors Clean
Accessing Diagnostic Trouble Codes and Addresses
Accessing Diagnostic Addresses Menu
Viewing Diagnostic Addresses
Changing Diagnostic Addresses
Accessing Diagnostic Readings Pages
Access Instructions
Accessing Diagnostic Trouble Codes Menu
Accessing Technician Mode
Access Manager Password Retrieval
Diagnostic Readings
Diagnostic Readings Table
Front Control Unit Readings
Front Control Unit, Page 1
Front Control Unit, Page 2
Front Control Unit, Page 3
Front Control Unit, Page 4
Front Control Unit, Page 5
Rear Control Unit Readings
Rear Control Unit, Page 1
Rear Control Unit, Page 2
Rear Control Unit, Page 3
Rear Control Unit, Page 4
Rear Control Unit, Page 5
Rear Control Unit, Page 6
Cab Control Unit Readings
Cab Control Unit, Page 1
Cab Control Unit, Page 2
Cab Control Unit, Page 3
Cab Control Unit, Page 4
Cab Control Unit, Page 5
Cab Control Unit, Page 6
Cab Control Unit, Page 7
Cab Control Unit, Page 8
Cab Control Unit, Page 9
Cab Control Unit 1 Readings
Cab Control Unit 1, Page 1
Cab Control Unit 1, Page 2
Cab Control Unit 1, Page 3
Cab Control Unit 1, Page 4
Cab Control Unit 1, Page 5
Cab Control Unit 1, Page 6
Cab Control Unit 1, Page 7
Cab Control Unit 1, Page 8
Cab Control Unit 1, Page 9
Contour Base Cutter Height Control Readings
Contour Base Cutter Height Control, Page 1
Contour Base Cutter Height Control, Page 2
Contour Base Cutter Height Control, Page 3
Contour Base Cutter Height Control, Page 4
Contour Base Cutter Height Control, Page 5
Climate Control Readings
Climate Control, Page 1
Climate Control, Page 2
Climate Control, Page 3
Climate Control, Page 4
Climate Control, Page 5
Climate Control, Page 6
Topper Readings
Topper, Page 1
Topper, Page 2
Knock Down Readings
Knock Down, Page 1
Side Knife Readings
Side Knife, Page 1
Side Knife, Page 2
Crop Divider Tilt Readings
Crop Divider Tilt, Page 1
Crop Divider Tilt, Page 2
Crop Divider Readings
Crop Divider, Page 1
Crop Divider, Page 2
Crop Divider, Page 3
Crop Divider, Page 4
Crop Divider, Page 5
Base Cutter Height Readings
Base Cutter Height, Page 1
Base Cutter Height, Page 2
Base Cutter Height, Page 3
Base Cutter Height, Page 4
Base Cutter Height, Page 5
Base Cutter Height, Page 6
Base Cutter Height, Page 7
Harvesting Readings
Harvesting, Page 1
Harvesting, Page 2
Harvesting, Page 3
Harvesting, Page 4
Cleaning Fan Readings
Cleaning Fan, Page 1
Cleaning Fan, Page 2
Elevator Swing System Readings
Elevator Swing System, Page 1
Elevator Swing System, Page 2
Elevator Drive System Readings
Elevator Drive System, Page 1
Elevator Drive System, Page 2
Elevator Drive System, Page 3
Elevator Drive System, Page 4
Elevator Drive System, Page 5
Propulsion Controls Readings (Track)
Propulsion Controls, Page 1
Propulsion Controls, Page 2
Propulsion Controls, Page 3
Propulsion Controls, Page 4
Propulsion Controls, Page 5
Propulsion Controls, Page 6
Propulsion Controls, Page 7
Propulsion Controls, Page 8
Propulsion Controls, Page 9
Propulsion Controls 1 Readings (Track)
Propulsion Controls 1, Page 1
Propulsion Controls 1, Page 2
Propulsion Controls 1, Page 3
Propulsion Controls 1, Page 4
Propulsion Controls 1, Page 5
Propulsion Controls 1, Page 6
Propulsion Controls 1, Page 7
Propulsion Controls 1, Page 8
Propulsion Controls 1, Page 9
Propulsion Controls 2 Readings (Track)
Propulsion Controls 2, Page 1
Propulsion Controls 2, Page 2
Propulsion Controls 2, Page 3
Propulsion Controls 2, Page 1
Propulsion Controls 2, Page 5
Propulsion Controls 2, Page 6
Propulsion Controls Readings (Wheel)
Propulsion Controls, Page 1
Propulsion Controls, Page 2
Propulsion Controls, Page 3
Propulsion Controls, Page 4
Propulsion Controls, Page 5
Propulsion Controls, Page 6
Propulsion Controls, Page 7
Propulsion Controls, Page 8
Propulsion Controls 1 Readings (Wheel)
Propulsion Controls 1, Page 1
Propulsion Controls 1, Page 2
Propulsion Controls 1, Page 3
Propulsion Controls 1, Page 4
Propulsion Controls 1, Page 5
Propulsion Controls 1, Page 6
Propulsion Controls 1, Page 7
Cooling Fan Readings
Cooling Fan, Page 1
Cooling Fan, Page 2
Engine Readings
Engine, Page 1
Engine, Page 2
Engine, Page 3
Engine, Page 4
Engine, Page 5
Engine, Page 6
Engine, Page 7
Engine, Page 8
Engine Tier 2 Stage II Readings
Engine Tier 2 Stage II , Page 1
Engine Tier 2 Stage II , Page 2
Engine Tier 3 Stage IIIA Readings
Engine Tier 3 Stage IIIA, Page 1
Engine Tier 3 Stage IIIA, Page 2
Engine Tier 3 Stage IIIA, Page 3
Engine Tier 3 Stage IIIA, Page 4
Front Lights Readings
Front Lights, Page 1
Front Lights, Page 2
Front Lights, Page 3
Front Lights, Page 4
Rear Lights Readings
Rear Lights, Page 1
Rear Lights, Page 2
Rear Lights, Page 3
Rear Lights, Page 4
Rear Lights, Page 5
Programming Control Units
Programming Control Units
Interactive Tests and Calibrations
Base Cutter Target Height Calibration
When to calibrate:
Base Cutter Height Calibration
Calibration Mode
Propulsion Steering Control (PSC) and Power Train Propulsion (PTP) Calibration
Theory of Operation
Automatic Temperature Control Unit (ATC) -Theory of Operation
Cab Control Unit (CAB) – Theory of Operation
Cab Switch Module (CSM) – Theory of Operation
Engine Control Unit (ECU) Level 14 – Theory of Operation
Front Control Unit (FCU) – Theory of Operation
Multi-Function Handle Control Unit (MHC) – Theory of Operation
Primary Display Unit (PDU) – Theory of Operation
Propulsion and Steering Control Unit (PSC) – Theory of Operation
Propulsion Control Unit (PTP) – Theory of Operation
Rear Control Unit (RCU) – Theory of Operation
Steering Control Lever (SCL) – Theory of Operation
Schematics
Automatic Temperature Control Unit (ATC) Electrical Schematic
ATC (A83) Pin Functions
Key Switch (S1) Pin Function
Additional Information
Cab Control Unit (CAB) Electrical Schematic
CAB (A6) Pin Function
Key Switch (S1) Pin Function
Additional Information
Cab Switch Module (CSM) Electrical Schematic
Cab Control Unit (A6) Pin Function
Cab Switch Module (A84) Pin Function
Key Switch (S1) Pin Function
Additional Information
Engine Control Unit (ECU) Level 14 (T2 or T3) Electrical Schematic
Propulsion Control Unit (A9) Pin Function
Engine Control Unit (A44) Pin Function
Key Switch (S1) Pin Function
Additional Information
Front Control Unit (FCU) Electrical Schematic
Front Control Unit (A58) Pin Function
Key Switch (S1) Pin Function
Additional Information
Multi-Function Lever Control Unit (MHC) Electrical Schematic
CAB (A6) Pin Function
Multi-function Lever (A28) Pin Function
Additional Information
Primary Display Unit (PDU) Electrical Schematic
Primary Display Unit (A88) Pin Function
Key Switch (S1) Pin Function
Additional Information
Propulsion and Steering Control Unit (PSC) Electrical Schematic
Propulsion Control Unit (A9) Pin Function
Key Switch (S1) Pin Function
Additional Information
Propulsion Control Unit (PTP) Electrical Schematic
Propulsion Control Unit (A9) Pin Function
Key Switch (S1) Pin Function
Additional Information
Rear Control Unit (RCU) Electrical Schematic
Rear Control Unit (A59) Pin Function
Key Switch (S1) Pin Function
Additional Information
Steering Control Lever (SCL) Electrical Schematic
Steering Control Lever (A89) Pin Function
Key Switch (S1) Pin Function
Additional Information
Tests and Adjustments
VIN Security Fault Diagnosis
Automatic Temperature Control Unit (ATC) – Diagnostics
Cab Control Unit (CAB) – Diagnostics
Cab Switch Module (CSM) – Diagnostics
Engine Control Unit (ECU) Level 14 – Diagnostics
Multi-Function Handle Control Unit (MHC) – Diagnostics
Primary Display Unit (PDU) – Diagnostics
PSC and PTP Control Units Test
Steering Control Lever (SCL) – Diagnostics
Automatic Temperature Control Unit Software Addresses (ATC)
ATC Diagnostic Addresses List
Cab Control Unit Software Addresses (CAB)
CAB Diagnostic Addresses List
Cab Switch Module Software Addresses (CSM)
CSM Diagnostic Addresses List
Cane Yield Monitor (CYM)
CYM Diagnostic Addresses List
Engine Control Unit Software Addresses (ECU)
ECU Diagnostic Addresses List
Engine Interface Control Unit Software Addresses (EIC)
EIC Diagnostic Addresses List
Front Control Unit Software Addresses (FCU)
FCU Diagnostic Addresses List, 0—151
FCU Diagnostic Addresses List, 152—194
Improved Height Control Unit Software Addresses (IHU)
IHU Diagnostic Addresses List, 0—49
IHU Diagnostic Addresses List, 50—155
IHU Diagnostic Addresses List, 156—251
Multi – Function Handle Control Unit Software Addresses (MHC)
MHC Diagnostic Addresses List
Primary Display Unit Software Addresses (PDU)
PDU Diagnostic Addresses List
Propulsion and Steering Control Unit Software Addresses (PSC)
PSC Diagnostic Addresses List, 0—99
PSC Diagnostic Addresses List, 100—251
Propulsion Control Unit Software Addresses (PTP)
PTP Diagnostic Addresses List, 0—99
PTP Diagnostic Addresses List, 100—251
Rear Control Unit Software Addresses (RCU)
RCU Diagnostic Addresses List, 0—148
RCU Diagnostic Addresses List, 149—251
Steering Control Unit Software Addresses (SCL)
SCL Diagnostic Addresses List
Electrical Component Information
General Information
Summary of References
Wiring Harnesses
Interconnects and Ground Points
Fuses
Fuse Center
Wiring Harnesses
W01—Armrest Harness
W02—Mainframe Extension Harness (Wheel Machines)
W03—Mainframe Extension Harness (Track Machines)
W05—Cab Pedal Harness
W06—Cab Main Harness
W07—Engine Harness (Tier 2-Stage II and Tier 3-Stage IIIA Emissions)
W08—Front Frame Harness
W09—Mainframe Harness
W10—License Lamp Jumper Harness
W11—Elevator Harness
W12—Fuse Battery Power Harness
W13—Base Cutter Height Sensor Harness
W14—Crop Divider Position Sensor Harness
W15—Primary Extractor Jumper Harness
W16—Rear Frame Harness (Tier 2-Stage II and Tier 3-Stage IIIA Emissions)
W17—Fuel Filter Jumper Harness (Tier 2-Stage II and Tier 3-Stage IIIA Emissions)
W19—Tilt Platform Harness (Standard)
W20—Tilt Platform Harness (CE-CMVR)
W21—Steering Column Harness
W22—Roof Harness
W23—HVAC Harness
W24—Tail Lights Jumper Harness (CE-CMVR)
W25—Light Extension Harness (CE-CMVR)
W26—Signal Lights Harness (CE-CMVR)
W29—Cooling Package Harness (Tier 2-Stage II and Tier 3-Stage IIIA Emissions)
W38—Vehicle Electrical Center (VEC) Battery Power Harness
W41—Yield Monitor Harness
W42—Yield Monitor Elevator Extension Harness
W43—Yield Monitor Data Cable Harness
W44—Yield Monitor Data Cable Extension Harness
W45—Yield Monitor Video Harness
W48—Right Tail Light Jumper Harness (LED Optional)
W49—Left Tail Light Jumper Harness (LED Optional)
W56—Left Mirror Extension Harness
W58—Right Mirror Extension Harness
Interconnects and Ground Points
X2—JDPS Harness Connector
X10—Mainframe Extension Harness-to-Tail Lights Jumper Harness Connector (CE-CMVR)
X11—Tail Lights Connector
X100—Front Frame Harness-to-Tilt Platform Harness Connector
X150—Front Harness Connector-to-Light Extension Harness (CE-CMVR)
X150-1—CE Extension Harness
X150-2—CE Extension Harness
X150-3—Front Harness
X160—Light Extension Harness (CE-CMVR)-to-Signal Lights Harness (CE-CMVR) Connector
X200-1—Engine Harness-to-Front Harness Connector (31-pin)
X200-4—Engine Harness-to-Front Harness Connector (21-pin)
X300—Mainframe Harness-to-Front Frame Harness Connector (31-pin)
X301—Mainframe Harness-to-Front Frame Harness Connector (18-pin)
X350—Main Frame Harness-to-Cooling Package Harness Connector
X402—Rear Frame Harness-to-Cooling Package Harness Connector
X450—Rear Frame Harness-to-License Lamp Harness Connector
X500—Mainframe Harness-to-Mainframe Extension Harness Connector
X502—Main Frame Harness-to-Primary Extractor Jumper Connector (1-pin)
X503—Main Frame Harness-to-Primary Extractor Jumper Connector (2-pin)
X504—Main Frame Harness-to-License Lamp Harness Connector
X508—Front Wiper Motor Connector
X510—Microphone Connector
X513—Roof Harness-to-GreenStar™ Display Extension Harness Connector
X517—Mirror Heater Switch Connector
X518—Cab Roof Light #1 Connector
X519—Cab Roof Light #2 Connector
X520—Cab Roof Light #3 Connector
X521—Cab Roof Light #4 Connector
X522—Cab Roof Light #5 Connector
X523—Cab Roof Light #6 Connector
X524—Cab Roof Light #7 Connector
X525—Cab Roof Light #8 Connector
X526—Left Radio Speaker Connector
X527—Right Radio Speaker Connector
X529—Dome Light Connector
X539-1—Door Switch Connector (Black Wire)
X539-2—Door Switch Connector (Brown Wire)
X543—Mirror Position Switch Connector
X552—GreenStar™ GPS Receiver Connector
X553—Cab Control Unit (CAB) Connector (J1)
X554—Cab Control Unit (CAB) Connector (J2)
X555—Cab Control Unit (CAB) Connector (J3)
X556—Cab Power Module (CPMA) Connector (J1)
X557—Cab Power Module (CPMA) Connector (J2)
X558—Cab Power Module (CPMA) Connector (J3)
X559—Diode Module Connector
X561—Main CAN Bus Active Terminator Connector
X566—Front Frame Harness-to-Roof Harness Connector
X567—Cab Main Harness-to-Front Frame Harness Connector (Black, 12-pin)
X568—Cab Main Harness-to-Front Frame Harness Connector (Gray, 8-pin)
X569—Cab Main Harness-to-Front Frame Harness Connector (Black, 8-pin)
X570—Cab Main Harness-to-Front Frame Harness Connector (Gray, 12-pin)
X571—Cab Main Harness-to-Roof Harness Connector
X572-1—Roof Harness-to-HVAC Harness Connector
X572-2—Roof Harness-to-HVAC Harness Connector
X580—Cab CAN Bus Active Terminator Connector
X596-1—Cab Main Harness-to-Cab Pedal Harness Connector
X596-2—Cab Pedal Harness-to-Steering Column Harness Connector
X599-1—Key Switch Connector (8-pin)
X600—Mainframe Extension Harness-to-Elevator Harness Connector
X603-1—Horn 1A Connector (Green Wire)
X603-2—Horn 1A Connector (Black Wire)
X604—Park Brake Switch Connector
X608—Start Aid Switch Connector
X610—Elevator Position Sensor Connector
X614—HVAC Low Pressure Sensor Connector
X615—Auxiliary Power Strip Connector
X617—CAN Bus Diagnostic Connector
X618—Temperature Door Actuator Connector
X619—Air Flow Mode Door Actuator Connector
X620—Pressurizer Fan Motor Connector
X622—Recirculation Fan Motor Connector
X624-1—Recirculation Fan Motor Driver Connector (6-pin)
X624-2—Recirculation Fan Motor Driver Connector (2-pin)
X625—Fresh Air Temperature Sensor Connector
X626-1—Seat Switch Connector (2-pin)
X626-2—Seat Switch Connector (3-pin)
X628—Cab Air Temperature Sensor Connector
X630—Automatic Temperature Control Unit (ATC) Connector
X631—Diode Module Fuse Connector
X632—Armrest Harness-to-Propulsion Control Harness Connector
X633—Case-Duct Temperature Sensor Connector
X634—Evaporator Temperature Sensor Connector
X635—Multi-Function Lever Forward Switch Connector
X636—Multi-Function Lever Reverse Switch Connector
X637—Neutral Gate Switch Connector
X638—Auxiliary Power Outlet 1 Connector
X639—Auxiliary Power Outlet 2 Connector
X656—Auxiliary Function Switch Connector
X657—Harvesting Functions Engage Switch Connector
X667—Multi-Function Control Lever Connector
X668—Cab Main Harness-to-Armrest Harness Connector
X669—Armrest Switch Matrix (ASM) Connector (J1)
X672—Armrest Switch Matrix (ASM) Connector (J2)
X677—Multi-Function Lever Position Sensor Connector
X700—Front Frame Harness-to-Crop Divider Position Sensor Harness
X700
X700
X800—Front Frame Harness-to-Base Cutter Height Sensor Harness Connector
X800—Height Sensor Harness
X800-1—Height Sensor Harness
X800-2—Height Sensor Harness
X900—Front Aux CAN Connector
X901—Front Aux CAN Power Connector
X902—Front Aux Bat Power Connector
X903—Rear Aux Bat Power Connector
X904—Rear Aux CAN Connector
X905—Rear Aux Power Connector
X906—Speed Sensors Connector
X910—Armrest Video Feed #1 Connector
X911—Armrest Video Feed #2 Connector
X913—Corner Post Video Feed Connector
X1000—Yield Monitoring Harness to Yield Monitor Elevator Extension Harness
X1001—Yield Monitor High-Speed Data Cable Connector 1
X1002—Yield Monitor High-Speed Data Cable Connector 2
X1003—Yield Monitor High-Speed Data Cable Connector 3
X1004—Yield Monitor Video Harness Connector 1
X4200—Radio Connector (10-pin)
X4201—Radio Connector (6-pin)
X4204—Radio Connector (16-pin)
X4208—HVAC Ground Connector
X4209—Horn Ground Connector
X4211—Roof Ground Connector
X5018—LPFS Interconnect Connector
X8331—Roof Harness-to-Left Mirror Extension Harness Connector
X8332—Roof Harness-to-Right Mirror Extension Harness Connector
X8519—Right Cab Beacon Connector
X8528—Map Light Connector
X8531—Left Cab Beacon Connector
X8546—Primary Display Unit (PDU) Connector
X8565—Steering Column Module Connector
X8566—Refrigerator Connector
X8574—Cab Switch Module (CSM) Connector
X8575—Cab Main Harness-to-Telematics Harness Connector
X8577—Cab Roof Left Wiper Extension Connector
X8578—Cab Roof Right Wiper Extension Connector
X8586—Subwoofer Assembly Connector
X8602—Horn 2 Connector
X8603—Warning Horn Connector
X8607—Horn 1 Connector
X8736-1—Radio Power Swap Connector
X8736-2—Radio Power Swap Connector
X8903—Radio Auxiliary Input Connector
X8936—Not Used
X8957—Cab CAN Bus Passive Terminator Connector
X8961—Armrest Harness-to-Secondary Display Unit (SDU) Harness Connector
X8968—Cab Refrigerator Thermostat Connector
X8969—Cab Refrigerator Control Unit Harness Connector
X8970—Cab Refrigerator Compressor Unit Connector
X8971—Cab Refrigerator Control Unit Power Connector
X8972—Cab Refrigerator Power Connector
X9005—Alternator Diode Connector
XA9-1—Propulsion Control Unit Connector (J1)
XA9-2—Propulsion Control Unit Connector (J2)
XA9-3—Propulsion Control Unit Connector (J3)
XA16—Steering Input Device Connector
XA44-2—Engine Control Unit (ECU) Connector (J2) (Tier 2-Stage II and Tier 3-Stage IIIA Emissions)
XA51—Vehicle Electrical Center (VEC) Connector
XA51-1—Vehicle Electrical Center (VEC) Connector (J4)
XA51-2—Vehicle Electrical Center (VEC) Connector (J5)
XA51-3—Vehicle Electrical Center (VEC) Connector (J8)
XA51-4—Vehicle Electrical Center (VEC) Connector (J9)
XA58-1—Front Control Unit Connector (J1)
XA58-2—Front Control Unit Connector (J2)
XA58-3—Front Control Unit Connector (J3)
XA58-4—Front Control Unit Connector (J4)
XA59-1—Rear Control Unit Connector (J1)
XA59-2—Rear Control Unit Connector (J2)
XA59-3—Rear Control Unit Connector (J3)
XA59-4—Rear Control Unit Connector (J4)
XA102—Main CAN Bus Passive Terminator Connector
XA102-1—Yield Monitor Harness to Mainframe Harness
XA200—Cane Yield Monitor Control Unit Connector (J1)
XA201—Wireless Communication Radio
XA203—Wagon Wireless Radio Connector
XA204—Wagon Wireless Radio to Scale Connector
XB8—Base Cutter Pressure Sensor Connector
XB9—Fuel Level Sensor Connector
XB12—Primary Hydraulic Oil Level Switch Connector
XB13—Secondary Hydraulic Oil Level Switch Connector
XB14—Hydraulic Oil Filter Restriction Connector
XB18—Hydraulic Oil Temperature Sensor Connector
XB24—Left Base Cutter Height Sensor Connector (Track)
XB25—Coolant level Sensor Connector
XB27—Right Base Cutter Height Sensor Connector (Track)
XB29—Left Base Cutter Height Sensor Connector (Wheel)
XB30—Right Base Cutter Height Sensor Connector (Wheel)
XB45—Left Crop Divider Pressure Sensor Connector
XB46—Right Crop Divider Pressure Sensor Connector
XB47—Right Motor Speed Sensor Connector
Wheel Machines
Track Machines
XB48—Left Motor Speed Sensor Connector
XB49—Park Brake Pressure Sensor Connector
XB52—Primary Extractor Speed Sensor Connector
XB56—Chopper Pressure Sensor Connector
XB58—Left Crop Divider Position Sensor Connector
XB60—Right Crop Divider Position Sensor Connector
XB64—Base Cutter Speed Sensor Connector
XB200—Elevator Speed Sensor
XB5107—Fuel Pressure Sensor Connector
XB5600—Water-In-Fuel Sensor Connector
XE20—Right Elevator Field Light Connector
XE22—Right Side Field Light Connector
XE23—Left Side Field Light Connector
XE24—Left Elevator Field Light Connector
XE25—Topper Boom Light Connector
XE26—Engine Work Light #1 Connector
XE27—Engine Work Light #2 Connector
XE28—Right Rear Beacon Light Connector
XE29—Left Rear Beacon Light Connector
XE30-1—License Lamp Connector
XE30-2—License Lamp Connector
XE31—Left Front Signal Light (CE) Connector
XE32—Right Front Signal Light (CE) Connector
XE35—Left Rear Vehicle Lights Connector
XE36—Right Rear Vehicle Lights Connector
XE37—Right Rear Turn Lamp
XE38—Left Rear Turn Lamp
XE39—Right Stop/Tail Lamp
XE40—Left Stop/Tail Lamp
XE41—Right Reverse Lamp
XE42—Left Reverse Lamp
XE47—Left Front Turn Light Connector
XE48—Right Front Turn Light Connector
XE49—Left Turn Amber Light Connector
XE50—Right Turn Amber Light Connector
XE67—Right Lower Driving Light Connector
XE68—Left Lower Driving Light Connector
XF88—Video Power Inline Fuse Connector
XF100—Front Control Unit Fuse Connector
XF101—Rear Control Unit Fuse Connector
XFUSE—Vehicle Electrical Center (VEC) Fuse Strip Connector
XGND—Frame Ground
XGND1—Front Left Frame Ground
XGND2—Front Right Frame Ground
XGND3—Rear Frame Ground Connector
XGND4—Cab Frame Ground
XGND5—Cab Main Ground Connector
XH19—Reverse Alarm Connector
XK60—Starter Relay Connector
XM1—Starter Motor Connector
XM5—Windshield Washer Pump Connector
XM6—Side Washer Pump Connector
XS4—Door Switch Connector
XS12-1—Battery Disconnect Switch Connector
XS12-2—Battery Disconnect Switch Connector
XS13—Air Filter Restriction Switch (Tier 2-Stage II and Tier 3-Stage IIIA Emissions)
XS25—Cab Tilt Switch Connector
XS81—Left Elevator Swing Pedals Connector
XS82—Right Elevator Swing Pedals Connector
XS84—Left Wheel Brake Pedal Connector (Wheel)
XS85—Right Wheel Brake Pedal Connector (Wheel)
XS86—AutoTrac™ Resume Pedal Connector (Track)
XS87—High/Low Ground Drive Pedal Connector (Track)
XX25—Topper Boom Light Interconnect
XX35—Left Tail Light Jumper Harness (LED Option) to Main Frame Extension Harness
XX36—Right Tail Light Jumper Harness (LED Option) to Main Frame Extension Harness
XX0118—Cab Main Harness-to-Auteq Communication Extension Harness Connector
XX0120—Cab Main Harness-to-Auteq Communication Extension Harness Connector
XVEC—Vehicle Electrical Center (VEC) Battery (+) Connector
XY1—Harvesting Functions FWD Solenoid Connector
XY2—Harvesting Functions REV Solenoid Connector
XY3—Right Crop Divider Raise Solenoid Connector
XY4—Right Crop Divider Lower Solenoid Connector
XY5—PCP Unloading Solenoid Connector
XY9—High-Low Solenoid Connector
XY10—Positive Traction Solenoid Connector
XY11—A/C Compressor Clutch Connector (Tier 2-Stage II and Tier 3-Stage IIIA Emissions)
XY12—Park Brake Solenoid Connector
XY15—Left Side Knife Solenoid Connector
XY16—Right Side Knife Solenoid Connector
XY17—Secondary Extractor Solenoid Connector
XY18—Elevator Swing Left Solenoid Connector
XY19—Elevator Swing Right Solenoid Connector
XY28—Left Crop Divider Raise Solenoid Connector
XY29—Left Crop Divider Lower Solenoid Connector
XY31—Left Crop Divider Tilt Forward Solenoid Connector
XY32—Left Crop Divider Tilt Rearward Solenoid Connector
XY34—Right Crop Divider Tilt Forward Solenoid Connector
XY35—Right Crop Divider Tilt Rearward Solenoid Connector
XY40—Primary Hood Rotate CW Solenoid Connector
XY41—Primary Hood Rotate CCW Solenoid Connector
XY42—Base Cutter Shutoff Solenoid Connector
XY43—Base Cutter Proportional Solenoid Connector
XY45—Right Base Cutter Lower Solenoid Connector
XY46—Left Base Cutter Lower Solenoid Connector
XY61—Base Cutter Pump Solenoid Connector
XY64—Cooling Fan Pump FWD Solenoid Connector
XY65—Cooling Fan Pump REV Solenoid Connector
XY69—Elevator Proportional Solenoid Connector
XY70—Secondary Extractor Hood Rotate CW Solenoid Connector
XY71—Secondary Extractor Hood Rotate CCW Solenoid Connector
XY72—Elevator Fwd Solenoid Connector
XY73—Elevator Rev Solenoid Connector
XY74—Elevator Up Solenoid Connector
XY75—Elevator Down Solenoid Connector
XY76—Upper Knockdown Roller In Solenoid Connector
XY77—Upper Knockdown Roller Out Solenoid Connector
XY78—Topper Raise Solenoid Connector
XY79—Topper Lower Solenoid Connector
XY81—Right Ground Drive Pump Solenoid Connector
XY82—Left Ground Drive Pump Solenoid Connector
XY83—Primary Extractor Pump Solenoid Connector
XY84—Chopper Pump Solenoid Connector
XY85—Left Crop Divider Accumulator Solenoid Connector
XY86—Right Crop Divider Accumulator Solenoid Connector
XY87—Topper Left Solenoid Connector
XY88—Topper Right Solenoid Connector
XY92—Left Side Knife Raise Solenoid Connector
XY93—Left Side Knife Lower Solenoid Connector
XY94—Right Side Knife Raise Solenoid Connector
XY95—Right Side Knife Lower Solenoid Connector
XY96—Lower Knockdown Roller Rearward Solenoid Connector
XY97—Lower Knockdown Roller Forward Solenoid Connector
XY102—Elevator Discharge Flap In Solenoid Connector
XY103—Elevator Discharge Flap Out Solenoid Connector
XY5501—Fuel Transfer Pump Connector
Drivetrain
General Information
Summary of References
Operational and Preliminary Checks
Hydrostatic Pump Charge Pressure Check
Hydrostatic Pump Vacuum Pressure Check
Hydraulic Specifications
Ground Drive Hydraulic Schematic (Track) – Hydraulic Specifications
Ground Drive Hydraulic Schematic (Track 2-Speed) – Hydraulic Specifications
Ground Drive Hydraulic Schematic (Wheel) – Hydraulic Specifications
Theory of Operation
Ground Drive Hydraulic (Track) – Theory of Operation
G081—Right Ground Drive Pump Assembly (Track)-Components
G047—Right Ground Drive Motor Assembly (Track)-Components
G082—Left Ground Drive Pump Assembly (Track)-Components
G048—Left Ground Drive Motor Assembly (Track)-Components
Ground Drive Hydraulic (Track 2-Speed) – Theory of Operation
G081—Right Ground Drive Pump Assembly (Track 2-Speed)-Components
G147—Right Ground Drive Motor Assembly (Track 2-Speed)-Components
G082—Left Ground Drive Pump Assembly (Track 2-Speed)-Components
G148—Left Ground Drive Motor Assembly (Track 2-Speed)-Components
Ground Drive Hydraulic (Wheel) – Theory of Operation
G110—Positive Traction Solenoid Valve Assembly (Wheel)-Components
G181—Right Ground Drive Pump Assembly (Wheel)-Components
G247—Right Ground Drive Motor Assembly (Wheel)-Components
G182—Left Ground Drive Pump Assembly (Wheel)-Components
G248—Left Ground Drive Motor Assembly (Wheel)-Components
Schematics
Ground Drive Hydraulic Schematic (Track)
Ground Drive Hydraulic Schematic (Track 2-Speed)
Ground Drive Hydraulic Schematic (Wheel)
Diagnostic Procedures
Hydrostatic Ground Drive Diagnostics—Wheel Machines
Related Information
Hydrostatic Ground Drive Diagnostics—Single-Speed Track Machines
Related Information
Hydrostatic Ground Drive Diagnostics—2-Speed Track Machines
Related Information
Tests and Adjustments
Left Ground Drive Pump Circuit Test
Right Ground Drive Pump Circuit Test
Propulsion Right and Left Motor Speed Sensor Circuit Test
Trim-Varitorq Potentiometer Calibration Procedure
Trim-Varitorq Potentiometer Circuit Test
Hydrostatic Pump Charge Pressure Check
Left Ground Drive Charge Pump (P382)
Right Ground Drive Charge Pump (P381)
Hydrostatic Pump Pressure Test
Left Ground Drive Pump (P082) Forward Test
Left Ground Drive Pump (P082) Reverse Test
Right Ground Drive Pump (P081) Forward Test
Right Ground Drive Pump (P081) Reverse Test
Hydrostatic Pump Flow Test
Wheel Machines
Track Machines
Hydrostatic Pump Pilot Control Pressure Test
Left Hydrostatic Drive Pump (P082)
Right Hydrostatic Drive Pump (P081)
Hydrostatic Pump Servo Pressure Test
Left Hydrostatic Drive Pump (P082)
Right Hydrostatic Drive Pump (P081)
Hydrostatic Motors Case Drain Test – Wheel Machines
Hydrostatic Motors Case Drain Test – Track Machines
Positive Traction Valve Test
Varitorque Servo Pressure Test
Drivetrain Component Information
General Information
Summary of References
Hydrostatic Drive Components
Hydrostatic Drive Components
Steering and Brakes
General Information
Summary of References
Brake Specifications
Theory of Operation
Park Brakes Theory of Operation
Service Brakes Theory of Operation
Steering Hydraulic Theory of Operation (Track Machine)
Steering Hydraulic Theory of Operation (Wheel Machine)
Schematics
Park Brake Hydraulic Schematic
Specifications
Related Information
Steering Hydraulic Schematics (Wheel Machine)
Specifications
Related Information
Diagnostics Procedures
Steering Hydraulic Diagnostics (Wheel Machine)
Related Information
Diagnostic Procedure
Park Brake Hydraulic Diagnostics
Related Information
Diagnostic Procedure
Tests and Adjustments
Steering Test Procedure (Wheel)
Multi-Function Control Lever Calibration Procedure
Steering Input Device (SID) Calibration Procedure
Hydrostatic Pump Displacement Calibration Procedure
Factory PWM Displacement Calibration
Field Deadband Calibration Procedure
Calibration Errors
Display
Multi-function control lever Calibration Errors:
SID Calibration Errors:
Factory Calibration Errors:
Trim Potentiometer Calibration Errors:
Field Calibration Errors:
Propulsion Motor Speed Sensor Installation Adjustment
Steering and Brakes Component Information
General Information
Summary of References
Steering Components
Steering Component
Park Brake Components
Park Brake Components
Hydraulic System
General Information
Summary of References
Hydraulic Specifications
Base Cutter System
Chopper System
Elevator System
Cooling Fan System
Cylinder Function Pump
Extractor Pump System
Main Pressure Relief Valve
Standard Hydraulic Symbols
Hydraulic Designators
Hydraulic System Testing Precautions
Visually Inspect Hydraulic System
Hydraulic Troubleshooting Tips
Aeration and Cavitation
Hydraulic Components
Oil Storage and Filling
Oil Filtration
Theory of Operation
Base Cutter and Chopper (Standard) Hydraulic – Theory of Operation
Engaged in Forward
Engaged in Reverse
Base Cutter (High Performance) Hydraulic – Theory of Operation
Engaged in Forward
Engaged in Reverse
Chopper (High performance) Hydraulic – Theory of Operation
Engaged in Forward
Engaged in Reverse
Cylinder Functions (Track) Hydraulic Theory of Operation
Base Cutter Lift
Crop Dividers and Knockdown Rollers Tilt
Crop Divider Lift
Elevator Discharge Flap and Secondary Extractor Hood Rotate
Elevator Lift
Elevator Swing
Side Knives Tilt
Topper Lift
Cylinder Functions (Wheel) Hydraulic Theory of Operation
Steering Cylinders and Priority Valve
Base Cutter Lift
Crop Dividers and Knockdown Rollers Tilt
Crop Divider Lift
Elevator Discharge Flap and Secondary Extractor Hood Rotate
Elevator Lift
Elevator Swing
Side Knives Tilt
Topper Lift
Elevator Drive and Secondary Extractor (Optional) Hydraulic – Theory of Operation
Elevator Drive with Variable Speed and Secondary Extractor (Optional) Hydraulic – Theory of Operation
Feed Roller with Side Knife Hydraulic Theory of Operation
Crop Divider and Outer Scroll Rotation
Feed Rollers Rotation
Knockdown Roller and Collector Rotation
Topper and Side Knives Rotation
Feed Roller without Side Knife Hydraulic Theory of Operation
Crop Divider and Outer Scroll Rotation
Feed Rollers Rotation
Knockdown Roller and Collector Rotation
Topper Rotation
Primary Extractor and Cooling Fan Hydraulic – Theory of Operation
Primary Extractor
Cooling Fan
Schematics
Base Cutter and Chopper (Standard) Hydraulic Schematic
Schematic
Specifications
Related Information
Base Cutter (High performance) Hydraulic Schematic
Schematic
Specifications
Related Information
Chopper (High performance) Hydraulic Schematic
Schematic
Specifications
Related Information
Cylinder Functions (Track) Hydraulic Schematic
Schematic
Specifications
Related Information
Cylinder Functions (Wheel) Hydraulic Schematic
Schematic
Specifications
Related Information
Elevator Drive and Secondary Extractor (Optional) Hydraulic Schematic
Elevator in Neutral
Elevator in Forward
Elevator in Reverse
Specifications
Related Information
Elevator Drive with Variable Speed and Secondary Extractor (Optional) Hydraulic Schematic
Elevator in Neutral
Elevator in Forward
Elevator in Reverse
Specifications
Related Information
Feed Roller with Side Knife Hydraulic Schematic
Overall Schematic
Feed Circuit—Forward
Feed Circuit—Reverse
Topper—Left
Topper—Right
Side Knife
Crop Divider
Knockdown Roller
Specifications
Related Information
Feed Roller without Side Knife Hydraulic Schematic
Schematic
Specifications
Related Information
Primary Extractor and Cooling Fan Hydraulic Schematic
Schematic
Specifications
Related Information
Diagnostic Procedures
Base Cutter Drive Hydraulic Diagnostics (Standard)
Related Information
Base Cutter Drive Hydraulic Diagnostics (High Performance)
Related Information
Base Cutter Lift Hydraulic Diagnostics
Related Information
Chopper Drive Hydraulic Diagnostics (Standard or High Performance)
Related Information
Cooling Fan Hydraulic Diagnostics
Related Information
Diagnostics
Crop Divider Lift Hydraulic Diagnostics
Related Information
Crop Divider Tilt Hydraulic Diagnostics
Related Information
Elevator Drive (without Variable Speed) Hydraulic Diagnostics
Related Information
Elevator Drive (with Variable Speed) Hydraulic Diagnostics
Related Information
Elevator Discharge Flap Hydraulic Diagnostics
Related Information
Elevator Swing Hydraulic Diagnostics
Related Information
Elevator Up and Down Hydraulic Diagnostics
Related Information
Feed Circuit Hydraulic Diagnostics
Related Information
Diagnostic Procedure
Knock Down Roller Tilt Hydraulic Diagnostics
Related Information
Knockdown Roller Rotation Hydraulic Diagnostics
Related Information
Primary Hood Rotate Hydraulic Diagnostics
Related Information
Primary Extractor Fan Drive Hydraulic Diagnostics
Secondary Extractor Hood Hydraulic Diagnostics
Related Information
Side Knife Tilt Hydraulic Diagnostics
Related Information
Topper Raise Hydraulic Diagnostics
Related Information
Cylinder Pump (P009) Diagnostics
Related Information
Tests and Adjustments
JT02156A Digital Pressure/Temperature Analyzer Installation
Heating Hydraulic Oil
Solenoid Valve Neutral Adjustment
Adapters and Fittings:
Base Cutter Pump (G061) Pressure Test
Charge Pressure
Stall Pressure
Base Cutter Pump (G061) Case Drain Test
Base Cutter Pump (G061) Flow Test
Chopper Pump (G084 or G184) Pressure Test
Charge Pressure
Stall Pressure
Chopper Pump (G084 or G184) Case Drain Test
Chopper Pump (G084 or G184) Flow Test
Base Cutter Motor (M008) Case Drain Test
Base Cutter Motor (M008) Relief Valve Test
Forward Relief Valve Pressure
Elevator Pump (P003) Flow Test
Rear Feed Pump (P004) Flow Test
Front Feed Pump (P005) Flow Test
Cooling Fan Pump (P702) Pressure Test
Charge Pressure
Operating Pressure
Stall Pressure
Cooling Fan Pump (P702) Flow Test
Hydraulic Cylinder Function Pump (P009) Pressure Test
Hydraulic Cylinder Function Pump (P009) Flow Test
Extractor Pump (P701) Pressure Test
Charge Pressure
Operating Pressure
Stall Pressure
Extractor Pump and Cooling Fan Pump Assembly (G700) Case Drain Test
Extractor and Cooling Fan Drive Pumps Servo Pressure Test
Cooling Fan
Primary Extractor Fan
Extractor Pump (P701) Flow Test
Chopper Motor Case Drain Test
Elevator Motors Case Drain Test
Elevator Drive Flow Test
Elevator Drive Flow With Variable Speed
Elevator Drive Flow Without Variable Speed
Feed Motors Case Drain Test
Knockdown Motors Case Drain Test
Main Pressure Relief Valve (V009) Test
Knockdown Roller Rotation Pressure Relief Valve (V020) Adjustment
Elevator Pressure Reduction Valve (V212) Test and Adjustment
Hydraulics Component Information
General Information
Summary of References
Accumulator
A004—Topper Lift Accumulator
A023—Elevator Lift Accumulator
A121—Left-Hand Base Cutter Lift Accumulator
A122—Right-Hand Base Cutter Lift Accumulator
A202—Left-Hand Crop Divider Lift Accumulator
A203—Right-Hand Crop Divider Lift Accumulator
Sensors
B45—Left Crop Divider Pressure Sensor
B46—Right Crop Divider Pressure Sensor
B49—Park Brake Pressure Sensor
Cylinder
C002—Left-Hand Crop Divider Lift Cylinder
C003—Right-Hand Crop Divider Lift Cylinder
C004—Topper Lift Cylinder
C005—Upper Knockdown Roller Tilt Cylinder
C006—Lower Knockdown Roller Tilt Cylinder
C007—Right-Hand Crop Divider Tilt Cylinder
C008—Left-Hand Crop Divider Tilt Cylinder
C010—Elevator Lift Right Cylinder
C011—Bin Flap Cylinder
C013—Elevator Lift Left Cylinder
C021—Left Steering Cylinder
C022—Right Steering Cylinder
C030—Right-Hand Side Knife Cylinder
C031—Left-Hand Side Knife Cylinder
C047—Right Park Brake Piston
C048—Left Park Brake Piston
C118—Elevator Swing Right Cylinder
C119—Elevator Swing Left Cylinder
C121—Left-Hand Base Cutter Lift Cylinder
Wheel Machines
Track Machines
C122—Right-Hand Base Cutter Lift Cylinder
Wheel Machines
Track Machines
Check Valve
D005—Thermal Bypass Valve 1
D006—Thermal Bypass Valve 2
D011—Elevator Lift Check Valve
D023—Bin Flap Check Valve
D025—Feed Flow Divider Check Valve (Left-hand)
D115—Billet Selector Check Valve
D118—Elevator Swing Check Valve
D119—Primary Extractor Hood Rotate Check Valve
D119 (Style A)
D119 (Style B)
D125—Feed Flow Divider Check Valve (Right-hand)
D143—Right Side Knife Tilt Check Valve
D144—Left Side Knife Tilt Check Valve
D145—Upper Knockdown Roller Tilt Check Valve
D146—Bottom Knockdown Roller Tilt Check Valve
D147—Right-hand Crop Divider Tilt Check Valve
D148—Left-Hand Crop Divider Tilt Check Valve
D321—Elevator Lift Check Valve
D322—Elevator Discharge Flap Check Valve
D389—Topper Motor Check Valve
D401—Right Crop Divider Check Valve 1
D402—Right Crop Divider Check Valve 2
D403—Right Crop Divider Check Valve 3
D404—Left Crop Divider Check Valve 4
D405—Left Crop Divider Check Valve 5
D406—Left Crop Divider Check Valve 6
D407—Left Basecutter Lift Check Valve
D408—Right Basecutter Lift Check Valve
Filters
F059—Triple In-tank Filter
Valve Block, Assembly, or Gearcase
G003—Remote Flushing Valve Assembly
G008—Base Cutter Motor Assembly
G014—Tilt Function Valve Assembly
G015—Elevator Swing Cushion Relief Assembly
G016—Secondary Cylinder Valve Assembly
Track Machine
Wheel Machine
G022—Elevator Main Relief Valve Assembly
G027—Elevator Variable Valve Assembly
G032—Elevator Valve Assembly
G033—Elevator and Feed Rollers Pump Assembly
G040—Cylinder Function Valve Assembly
G047—Right Ground Drive Motor Assembly (Track)
G048—Left Ground Drive Motor Assembly (Track)
G056—Chopper Motor Assembly
G061—Base Cutter Pump Assembly (High Performance)
G081—Right Ground Drive Pump Assembly (Track)
G082—Left Ground Drive Pump Assembly (Track)
G084—Chopper Pump Assembly (High Performance)
G089—Topper Rotation Valve Assembly
G090—Topper and Side Knives Rotation Valve Assembly
G101—Harvesting Functions Pilot Control Valve Assembly
G110—Positive Traction Solenoid Valve Assembly
G115—Billet Selector Valve Assembly
G119—Crop Divider Rotation Valve Assembly
G120—Knockdown Roller Rotation Valve Assembly
G121—Feed Roller Rotation Valve Assembly
G125—Feed Flow Divider Valve Assembly
G126—Upper Knockdown Feed Flow Divider Valve Assembly
G147—Right Ground Drive Motor Assembly (Track 2-Speed)
G148—Left Ground Drive Motor Assembly (Track 2-Speed)
G181—Right Ground Drive Pump Assembly (Wheel)
G182—Left Ground Drive Pump Assembly (Wheel)
G184—Base Cutter and Chopper Pump Assembly (Standard)
G200—Topper and Crop Divider Pump Assembly
G247—Right Ground Drive Motor Assembly (Wheel)
G248—Left Ground Drive Motor Assembly (Wheel)
G700—Primary Extractor and Cooling Fan Pump Assembly
Cooler
H001—Oil Cooler
Motor
M001—Left Outer Scroll Motor
M002—Left Crop Divider Motor
M003—Right Outer Scroll Motor
M004—Right Crop Divider Motor
M005—Left Lower Knockdown Motor
M006—Right Lower Knockdown Motor
M007—Left Upper Knockdown Motor
M008—Right Upper Knockdown Motor
M009—Left Butt-lifter Motor (B1)
M010—Right Butt-lifter Motor (B1)
M011—Top Feed Roller Motor (T1)
M012—Top Feed Roller Motor (T2)
M013—Top Feed Roller Motor (T3)
M014—Top Feed Roller Motor (T4)
M015—Top Feed Roller Motor (T5)
M016—Chopper Curtain Agitator Motor (T6)
M017—Sill Roller Motor (T7)
M019—Primary Hood Rotate Motor
M021—Cooling Fan Motor
M022—Primary Extractor Motor
M023—Secondary Extractor Motor
M024—Right Elevator Drive Motor
M026—Secondary Extractor Hood Rotate Motor
M032—Bottom Feed Roller Motor (B2)
M033—Bottom Feed Roller Motor (B3)
M034—Bottom Feed Roller Motor (B4)
M035—Bottom Feed Roller Motor (B5)
M039—Left Elevator Drive Motor
M087—Left Collector Motor
M088—Right Collector Motor
M089—Topper Severing Motor
M115—Left Side Knife Motor
M116—Right Side Knife Motor
Orifices
O011—Orifice
O032—Orifice
Pump
P003—Elevator Drive Pump
P004—Rear Feed Feed Rollers Pump
P005—Front Feed Feed Rollers Pump
P009—Cylinder Function Pump
P019—Crop Divider Rotation Pump
P081—Right Ground Drive Pump
P082—Left Ground Drive Pump
P089—Topper Rotation Pump
P381—Right Ground Drive Charge Pump
P382—Left Ground Drive Charge Pump
P700—Primary Extractor and Cooling Fan Charge Pump
P701—Primary Extractor Pump
P702—Cooling Fan Pump
Hydraulic Reservoir
R001—Hydraulic Reservoir
Valve
V007—Topper Boom Relief Valve
V008—Primary Hood Rotate Pressure Relief Valve
Track Machine
Wheel Machine
V009—Main Pressure Relief Valve
Track Machine
Wheel Machine
V012—Steering Valve
V013—Steering Priority Valve
V015—Billet Selector Valve
V017—Elevator Drive Relief Valve
V021—Feed Roller Rotation Pressure Relief Valve
V115—Pressure Relief Valve
V116—Pressure Relief Valve
V141—Bottom Knockdown Tilt Cylinder Flow Reduction Valve
V142—Upper Knockdown Tilt Cylinder Flow Reduction Valve
V143—Left-Hand Crop Divider Tilt Cylinder Flow Reduction Valve
V144—Left-Hand Knife Tilt Cylinder Flow Reduction Valve
V145—Right-Hand Crop Divider Tilt Cylinder Flow Reduction Valve
V146—Right-Hand Knife Tilt Cylinder Flow Reduction Valve
V167—Elevator Swing Flow Reduction Valve
V168—Primary Extractor Hood Rotate Flow Reduction Valve
V169—Elevator Valve Assembly Flow Reduction Valve
V212—Elevator Pressure Reduction Valve
V213—Load Sense Relief Valve
V221—Left-Hand Basecutter Lift Cylinder Pressure Relief Valve
V222—Right-Hand Basecutter Lift Cylinder Pressure Relief Valve
V321—Logic Control Valve
V322—Logic Control Valve
V323—Logic Control Valve
V324—Logic Control Valve
V384—Charge Pressure Relief Valve
V401—Left Crop Divider Raise Control Valve
V402—Right Crop Divider Raise Control Valve
V411—Left-Hand Basecutter Raise Pressure Compensator Valve
V412—Right-Hand Basecutter Raise Pressure Compensator Valve
V515—Feed Rollers Logic Control Valve
V700—Primary Extractor and Cooling Fan Charge Pressure Relief Valve
Diagnostic Receptacle
X019—Crop Divider Rotation Pump Diagnostic Receptacle
X020—Front Feed Pump Diagnostic Receptacle
X021—Rear Feed Pump Diagnostic Receptacle
X022—Elevator Main Relief Valve Diagnostic Receptacle
X023—Elevator Motors Diagnostic Receptacle
X032—Elevator Cylinders Diagnostic Receptacle
X040—Cylinder Pump Pressure Diagnostic Receptacle
X089—Topper Rotation Pump Diagnostic Receptacle
X161—Base Cutter Reverse Diagnostic Receptacle (High Performance)
X184—Chopper and Base Cutter Reverse Diagnostic Receptacle
X247—Right Wheel Motor Varitorq Diagnostic Receptacle
X248—Left Wheel Motor Varitorq Diagnostic Receptacle
X261—Base Cutter Forward Diagnostic Receptacle (High Performance)
X284—Chopper and Base Cutter Forward Diagnostic Receptacle (Standard)
X361—Base Cutter Charge Pressure Diagnostic Receptacle (High Performance)
X382—Hydrostatic Charge Pressure Diagnostic Receptacle
X384—Chopper and Base Cutter Charge Pressure Diagnostic Receptacle (Standard)
X701—Primary Extractor Pump Forward Diagnostic Receptacle
X702—Primary Extractor Pump Reverse Diagnostic Receptacle
X703—Cooling Fan Pump Forward Diagnostic Receptacle
X704—Cooling Fan Pump Reverse Diagnostic Receptacle
X705—Primary Extractor and Cooling Fan Charge Pump Diagnostic Receptacle
Solenoid Valve
Y1—Harvesting Functions Forward Solenoid Valve
Y2—Harvesting Functions Reverse Solenoid Valve
Y3—Right Crop Divider Raise Solenoid Valve
Y4—Right Crop Divider Lower Solenoid Valve
Y5—PCP Unloading Solenoid Valve
Y9—High-Low Solenoid Valve
Y12—Park Brake Solenoid Valve
Y17—Secondary Extractor Solenoid Valve
Y18-Y19—Elevator Swing Solenoid Valve
Y28—Left Crop Divider Raise Solenoid Valve
Y29—Left Crop Divider Lower Solenoid Valve
Y31-Y32—Left Crop Divider Tilt Solenoid Valve
Y34-Y35—Right Crop Divider Tilt Solenoid Valve
Y40-Y41—Primary Hood Rotate Solenoid Valve
Y42—Basecutter Shutoff Solenoid Valve
Y43—Basecutter Proportional Solenoid Valve
Y45—Right Basecutter Lower Solenoid Valve
Y46—Left Basecutter Lower Solenoid Valve
Y64—Cooling Fan Pump Forward Solenoid Valve
Y65—Cooling Fan Pump Reverse Solenoid Valve
Y70-Y71—Secondary Extractor Hood Rotate Solenoid
Y72—Elevator Forward Solenoid Valve
Y73—Elevator Reverse Solenoid Valve
Y74—Elevator Up Solenoid Valve
Y75—Elevator Down Solenoid Valve
Y76-Y77—Upper Knockdown Roller Raise and Lower Solenoid Valve
Y78—Topper Raise Solenoid Valve
Y79—Topper Lower Solenoid Valve
Y83—Primary Extractor Pump Solenoid Valve
Y85—Left Crop Divider Accumulator Solenoid Valve
Y86—Right Crop Divider Accumulator Solenoid Valve
Y92-Y93—Left Side Knife Raise and Lower Solenoid Valve
Y94-Y95—Right Side Knife Raise and Lower Solenoid Valve
Y96-Y97—Lower Knockdown Roller Forward and Rearward Solenoid Valve
Y102-Y103—Elevator Discharge Flap Solenoid Valve
Mechanical Systems
Theory of Operation
Chopper Gear Case Theory of Operation
Chopper Gear Case
Cab
General Information
Summary of References
Safety Precautions
Refrigerant Precautions
R134A Refrigerant Recover, Recycling and Charging System Installation Procedure
R134A Component Oil Charge
Recover R134A System
Evacuate R134A System
Charge R134A System
Specifications
Theory of Operation
HVAC (Heating, Ventilation and Air Conditioning) – Theory of Operation
Schematics
HVAC (Heating, Ventilation and Air Conditioning) – Schematics
Diagnostics
Heating, Ventilation, and Air Conditioning – Diagnostics
Servicing Air Conditioning
Leak Testing The Air Conditioning System With Dye
Leak Testing The Air Conditioning System With Electronic Leak Detector
System Pressure Test
Cab Component Information
General Information
Summary of References
Assembly
Cab Components
HVAC – Cab Roof
Filters
Recirculation Filter
Heat Exchangers
H1 – Condenser
H2 – Heater Core
H3 – Evaporator Core
Pumps
P1 – Compressor
Valves
V1 – Expansion Valve
Diagnostic and Service Port
X1 – High Pressure Service Port
X2 – Low Pressure Service Port
Tools
General Information
Summary of References
Dealer Fabricated Tools
DFRG11—Charge Air Cooler Leak Tester
DFT8T9—Dual Resistance Jumper Harness
Required Materials:
Recommended Tools (Electrical)
J-35616-20 – Test Lead Package
JDG144 – Crimping Pliers
JDG145 – Electrical Pliers
JDG359 – Electrical Repair Tool Kit
JDG707 – Crimping Pliers
JDG708 – Crimping Tool
JDG783 – Crimping Tool
JDG10145 – Crimping Tool
JDG10146 – Terminal Extractor
JDG10273 – Test Box
JDG10273P1 – Power Extension Cable (15 ft)
JDG10273P2 – Power Cable
JDG10466 – Flex Probe Kit
JDG10528 – Battery Tester
JDG11668 – Electrical Load Tester
JT05832 – Battery Load Tester
JT07195B – Electrical Repair Tool Kit
JT07306 – Digital Multimeter
Recommended Tools (Hydraulic)
0070028756 – Fitting (Elbow)
38H1098-90° Elbow (-16 ORFS Sw)
38H1150 – Plug (-16 ORFS)
38H1419 – Cap (-16 ORFS)
AE24616 – Adapter (Elbow)
CB01510120 – Diagnostic Receptacle
HXE21691 – Orifice Plug
JT02156A – Digital Pressure/Temperature Analyzer Kit
JT02160 – Transducer
JT02161 – 3500 kPa (350 bar) (500 psi) Transducer
JT07148 – Digital Hydraulic Flow Meter
R37202-Plug (-16) 37° Flare
T29439-Cap (-12) 37° Flare
T61120-Straight Fitting (-4) ORB X (-6) 37° Flare
T76557-Plug (-12) 37° Flare
U42984-Plug (-8) 37° Flare
U45826-Cap (-16) 37° Flare
X6C5OX-S-Elbow Fitting 37° Flare
X6R6X-S-T-Fitting (-6) 37° Flare
X8R6X-S-T-Fitting (-8) 37° Flare
X12FNTX-S-Cap (-12) 37° Flare
X12PNTX-S-Plug (-12) 37° Flare
X12WTX-WLN-S-Straight Fitting (-12) 37° Flare
XPD341- Diagnostic Receptacle (-4) ORB Male
XPD361 – Diagnostic Receptacle (-6) ORB Male
XPD36BTX-Diagnostic Receptacle (-6) 37° Flare
XPD38BTX-Diagnostic Receptacle (-8) 37° Flare
Recommended Tools (Other)
JT05709 – Reflective Tape
JT05719 – Hand Held Digital Tachometer
JT07253 – Infrared Temperature Gun
Page Number
Section 210
Group 05A
Group 05B
Group 05C
Section 211
Group ATC
Group CAB
Group CSM
Group CYM
Group EIC
Group FCU
Group IHU
Group MHC
Group PDU
Group PSC
Group PTP
Group RCU
Group SCL
Group 100
Section 212
Group 20
Group 30
Group 40
Group 45
Group 50
Group 60
Group 70
Group 90
Section 220
Group 05
Group 20
Group 30
Group 50
Section 230
Group 05
Group 10
Group 20
Group 50
Section 240
Group 05
Group 10
Group 20A
Group 20B
Group 20C
Group 20D
Group 20E
Group 20F
Group 20G
Group 20H
Group 30
Group 30A
Group 30B
Group 30C
Group 30D
Group 30E
Group 30F
Group 30G
Group 30H
Group 50A
Group 50B
Group 50C
Group 50D
Group 50E
Group 50F
Group 50G
Group 50H
Section 245
Group 05
Group 10A
Group 10B
Group 10C
Group 10D
Group 20
Group 30
Group 50
Group ATC
Group CAB
Group CSM
Group CYM
Group ECU
Group EIC
Group FCU
Group IHU
Group MHC
Group PDU
Group PSC
Group PTP
Group RCU
Group SCL
Section 249
Group 05
Group 40F
Group 40W
Group 40X
Section 250
Group 05
Group 10A
Group 10D
Group 20
Group 30
Group 50A
Group 50B
Section 259
Group 05
Group 40
Section 260
Group 05
Group 20
Group 30
Group 50A
Group 50B
Section 269
Group 05
Group 40A
Group 40B
Section 270
Group 05
Group 20
Group 30
Group 50A
Group 50B
Section 279
Group 05
Group 40A
Group 40B
Group 40C
Group 40D
Group 40F
Group 40G
Group 40H
Group 40M
Group 40O
Group 40P
Group 40R
Group 40V
Group 40X
Group 40Y
Section 280
Group 20
Section 290
Group 05
Group 20
Group 30
Group 50
Section 299
Group 05
Group 40A
Group 40F
Group 40H
Group 40P
Group 40V
Group 40X
Section 300
Group 05
Group 05A
Group 05B
Group 05C
Group 05D